SELVA MARINE Wahoo 15 Service Manual page 285

A.
Abbreviation ................................................1-3
Adjusting the pilot screw ...........................4-15
Adjusting the throttle cable
(remote control model)..............................3-8
Adjusting the throttle cable
(tiller handle model) ..................................3-7
Adjusting the throttle link.............................3-9
After test run .............................................1-19
Assembling the carburetor ........................4-13
Assembling the cylinder block...................5-58
Assembling the cylinder head ...................5-44
Assembling the drive shaft housing ..........6-15
Assembling the exhaust guide,
oil pan, and exhaust manifold .................7-16
Assembling the forward gear ....................6-14
Assembling the friction plate .......................7-6
Assembling the fuel pump...........................4-7
Assembling the gear pump .......................7-39
Assembling the lower case .......................6-14
Assembling the manual starter .................5-10
Assembling the power tilt motor................7-33
Assembling the propeller shaft assembly ...6-8
Assembling the propeller shaft housing ......6-9
Assembling the starter motor ....................8-17
Assembling the swivel bracket..................7-23
Assembling the tiller handle ........................7-3
Assembling the tilt cylinder .......................7-44
Assembling the upper case.......................7-17
B.
Backlash ...................................................6-23
Bleeding the power tilt unit........................7-46
Bottom cowling............................................7-8
Bow view.....................................................8-3
Bracket (electric starter model) .................5-24
Bracket (manual starter model).................5-22
Bracket unit ...............................................3-13
Break-in.....................................................1-19
C.
Carburetor.................................................4-10
Carburetor unit ............................................4-9
CDI unit and junction box
(manual tilt model) ..................................5-18
CDI unit and junction box
(power tilt model) ....................................5-20
Changing the engine oil ..............................3-3
Changing the gear oil................................3-14
Charging system
(electric starter model) ............................8-29
Checking the anode ..................................3-16
6AG3J11
Checking the battery................................. 3-17
Checking the battery
(electric starter model)............................ 1-14
Checking the bearing................................ 6-13
Checking the brush
holder and brush............................7-33
Checking the camshaft ............................. 5-43
Checking the carburetor ........................... 4-12
Checking the CDI unit............................... 8-25
Checking the charge coil .......................... 8-23
Checking the compression pressure .......... 5-1
Checking the connecting
rod big end side clearance ..................... 5-55
Checking the connecting
rod small and big end inside diameter.... 5-54
Checking the cooling water passage.......... 3-7
Checking the cooling water pilot hole ....... 1-18
Checking the crankpin oil clearance......... 5-55
Checking the crankshaft ........................... 5-55
Checking the crankshaft
journal oil clearance................................ 5-56
Checking the cylinder bore ....................... 5-52
Checking the cylinder head ...................... 5-38
Checking the diaphragm and valve ............ 4-7
Checking the drive shaft ........................... 6-13
Checking the drive shaft bushing
(L-transom model) .................................. 7-15
Checking the electrical component........... 8-11
Checking the engine idle speed ............... 3-11
Checking the engine oil .............................. 3-3
Checking the engine oil level.................... 1-13
Checking the engine start button or
switch and engine stop lanyard switch ... 1-18
Checking the engine start button
(tiller handle model with electric
starter) .................................................... 8-18
Checking the engine start switch
(remote control model) ........................... 8-19
Checking the engine stop lanyard switch
(remote control model) ........................... 8-24
Checking the engine stop lanyard switch
(tiller handle model) ................................ 8-24
Checking the exhaust manifold,
oil pan, and exhaust guide...................... 7-16
Checking the filter..................................... 7-39
Checking the fuel filter ................................ 3-3
Checking the fuel filter assembly................ 4-3
Checking the fuel joint ................................ 4-3
Checking the fuel joint and fuel hose
(fuel joint-to-carburetor) ............................ 3-2
Checking the fuel pump.............................. 4-6
Checking the fuel system ......................... 1-13
Checking the fuse..................................... 7-47
Index
1
,
8-16
2
3
4
5
6
7
8
9
i-1