Starter Motor Removal And Disassembly - Suzuki GSX1400 Service Manual

7-12 ELECTRICAL SYSTEM
Check the starter relay.
( 7-14)
Correct
The starter motor runs when the transmission is in neutral, but does not run when the transmission is in any
position other than neutral, with the side-stand up.
Check the side-stand switch.
( 7-15)
Correct
Others
Engine does not turn though
the starter motor runs.
STARTER MOTOR REMOVAL AND
DISASSEMBLY
• Remove the oil hose connector 1 from the crankcase.
• Disconnect the starter motor lead wire 2.
• Remove the starter motor.
• Disassemble the starter motor as shown in the illustration.
www.GSX1400FE.com
Incorrect
Incorrect
• Faulty starter clutch
• Faulty starter relay
• Poor contact of the starter relay
• Faulty side-stand switch
• Open circuit in wire harness
• Poor contact of connector
1 O-ring
2 Housing end (inside)
3 Starter motor case
4 Armature
5 Brush holder and spring
6 Housing end (outside)