Rear Suspension - Suzuki sq-416-420-625 Service Manual

NOTE:
D All suspension fasteners are an important attaching part in that it could affect the performance of vital
parts and systems, and/or could result in major repair expense. They must be replaced with one of the
same part number or with an equivalent part if replacement becomes necessary. Do not use a replace-
ment part of lesser quality or substitute design. Torque values must be used as specified during reas-
sembly to assure proper retention of this part.
D Never attempt to heat, quench or straighten any suspension part. Replace it with a new part, or damage
to the part may result.
GENERAL DESCRIPTION
DIAGNOSIS . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Table . . . . . . . . . . . . . . . . . . . . . .
Shock Absorber Check
Lower /Upper /Lateral Rod Check
Axle Housing and Coil Spring Check
Bearing Retainer & Axle Shaft Inner Oil
Seal Check . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel Disc, Nut & Bearing Check
ON-VEHICLE SERVICE
Shock Absorber . . . . . . . . . . . . . . . . . . . . . .
SECTION 3E

REAR SUSPENSION

CONTENTS
. . . . . . . . . . . . . . 3E- 2
3E- 3
3E- 3
. . . . . . . . . . . . . . . . 3E- 3
. . . . . . . . 3E- 3
. . . . 3E- 3
3E- 4
. . . . . . 3E- 4
. . . . . . . . . . . . . . . . 3E- 5
3E- 5
Coil Spring . . . . . . . . . . . . . . . . . . . . . . . . . .
Lower Rod . . . . . . . . . . . . . . . . . . . . . . . . . .
Upper Rod . . . . . . . . . . . . . . . . . . . . . . . . . .
Lateral Rod . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Axle Shaft and Wheel Bearing
Rear Axle Shaft Inner Oil Seal
Rear Axle Housing . . . . . . . . . . . . . . . . . . . .
TIGHTENING TORQUE
SPECIFICATIONS . . . . . . . . . . . . . . . . . . . .
REQUIRED SERVICE MATERIALS
SPECIAL TOOLS . . . . . . . . . . . . . . . . . . . . . .
REAR SUSPENSION 3E-1
3E- 6
3E- 8
3E- 9
3E-10
. . . . . 3E-10
. . . . . . . . . . 3E-15
3E-16
3E-23
. . . . . . 3E-23
3E-24
3E