Club Car 2009-20011 Electric Precedent Maintenance And Service Manual page 399

removal ........................................................... 9-4
suspension, rear (two-passenger)
leaf spring
installation ....................................................... 9-3
removal ........................................................... 9-2
sweater basket ....................................................... 4-9
T
test procedures
16-pin connector .............. 11-21, 12-23, 13-21, 14-22
batteries/voltage check ............................11-14,
12-14, 13-14, 14-14
battery pack voltage (under load) .............11-18,
12-20, 13-19, 14-20
battery warning light ................................11-34,
12-38, 13-34, 14-37
charger receptacle...................................11-30,
12-33, 13-30, 14-33
Forward/Reverse rocker switch ................11-32,
12-35, 13-32, 14-35
key switch........................ 11-20, 12-21, 13-20, 14-20
MCOR .................................................. 12-16, 14-16
MCOR limit switch ................................. 12-21, 14-20
motor, A1 and A2 voltage.........................11-17,
12-18, 13-17, 14-18
OBC gray wire and fuse...........................11-30,
12-33, 13-30, 14-33
OBC, rebooting ................ 11-34, 12-37, 13-34, 14-37
onboard computer SCR ...........................11-29,
12-32, 13-29, 14-32
onboard computer solenoid lockout
circuit............................. 11-15, 12-15, 13-15, 14-15
reverse buzzer ................. 11-33, 12-36, 13-33, 14-36
sensor
throttle position ............................................ 13-16
solenoid........................... 11-32, 12-35, 13-32, 14-35
solenoid activating coil.............................11-15,
12-16, 13-15, 14-15
solenoid diode....................................... 12-16, 14-15
speed sensor, motor ................................11-31,
12-34, 13-31, 14-34
throttle position sensor........................... 11-16, 13-16
throttle position sensor limit switch............11-20,
13-20
Tow/Run switch ................ 11-18, 12-19, 13-18, 14-19
test procedures, IQDM and IQDM-P
handset .................................................. 15-19, 16-20
test procedures, motor
1 internal short circuits....................................... 20-2
2 armature circuit open ...................................... 20-2
3 field circuit open ............................................. 20-3
armature ground test ......................................... 20-8
throttle position sensor ..................................... 5-3–5-4
replacement...................................................... 17-7
testing ..............................11-16, 11-20, 13-16, 13-20
tie rod and drag link
installation ........................................................ 7-13
removal ............................................................ 7-11
tire
Tow/Run switch ........................... 11-7, 12-7, 13-2, 14-2
transaxle, type g
troubleshooting............................ 11-2, 12-2, 13-3, 14-3
U
universal accessory mounting.................................. 4-9
W
walk away braking ....................... 11-1, 12-1, 13-2, 14-2
WARNING
water level
wheel
wheel liner
wheel, steering
wiring diagram............................. 11-2, 12-2, 13-3, 14-3
2009-2011 Electric Precedent Maintenance and Service Manual
installation .......................................................... 8-3
removal .............................................................. 8-2
repair.................................................................. 8-2
installation ........................................................ 17-6
removal ............................................................ 17-6
testing ............................. 11-18, 12-19, 13-18, 14-19
assembly ........................................................ 21-10
axle bearing ...................................................... 21-4
axle shaft
installation ..................................................... 21-4
removal ......................................................... 21-1
disassembly...................................................... 21-8
inspection ......................................................... 21-8
installation .......................................................21-11
lubrication ......................................................... 21-1
oil seal
installation ..................................................... 21-4
removal ......................................................... 21-1
removal ............................................................ 21-5
battery troubleshooting examples .............. 18-8,
18-14
communication display module (CDM)........... 11-
38, 12-40, 13-38, 14-40
IQDM and IQDM-P handset ................... 15-18, 16-19
troubleshooting guide 1............................. 11-8,
12-8, 13-8, 14-8
troubleshooting guide 2............................ 11-11,
12-11, 13-11, 14-11
definition of ......................................................... 1-1
see batteries, electrolyte level .......................... 18-19
installation .......................................................... 8-1
removal .............................................................. 8-1
see also tire ........................................................ 8-1
installation ........................................................ 4-11
removal ............................................................ 4-11
see steering wheel .............................................. 7-1
INDEX
Page i-5