Section 10 - Periodic Maintenance; General Warning - Club Car 2009-20011 Electric Precedent Maintenance And Service Manual

SECTION 10 – PERIODIC MAINTENANCE

GENERAL WARNING

The following safety statements must be heeded whenever the vehicle is being operated, repaired, or serviced. Service
technicians should become familiar with these general safety statements, which can be found throughout this manual.
Also, other specific safety statements appear throughout this manual and on the vehicle.
DANGER
• See General Warnings on page 1-1.
• Battery – Explosive gases! Do not smoke. Keep sparks and flames away from the vehicle and service
area. Ventilate when charging or using in an enclosed space. Wear a full face shield and rubber gloves
when working on or near batteries.
• Battery – Poison! Contains acid! Causes severe burns. Avoid contact with skin, eyes, or clothing.
Antidotes:
– External: Flush with water. Call a physician immediately.
– Internal: Drink large quantities of milk or water. Follow with milk of magnesia or vegetable
oil. Call a physician immediately.
– Eyes: Flush with water for 15 minutes. Call a physician immediately.
WARNING
• See General Warnings, Section 1, Page 1-1.
• Only trained technicians should repair or service the vehicle. Anyone doing even simple repairs or
service should have knowledge and experience in electrical and mechanical repair.
• Follow the procedures exactly as stated in this manual, and heed all DANGER, WARNING, and
CAUTION statements in this manual as well as those affixed to the vehicle.
• Improper use of the vehicle or failure to properly maintain it could result in decreased vehicle
performance or severe personal injury.
• Any modification or change to the vehicle that affects the stability or handling of the vehicle, or
increases maximum vehicle speed beyond factory specifications, could result in severe personal
injury or death.
• Check the vehicle owner's manual for proper location of all vehicle warning decals and make sure
they are in place and are easy to read.
• Wear safety glasses or approved eye protection when servicing the vehicle. Wear a full face shield and
rubber gloves when working on or near batteries.
• Do not wear loose clothing or jewelry such as rings, watches, chains, etc., when servicing vehicle.
• Moving parts! Do not attempt to service the vehicle while it is running.
• Hot! Do not attempt to service hot motor. Failure to heed this warning could result in severe burns.
WARNING CONTINUED ON NEXT PAGE
2009-2011 Electric Precedent Maintenance and Service Manual
10
Page 10-1