Nilfisk-ALTO FLOORTEC R 870 Service Manual page 10

Service Manual – Floortec R 870
– The machine maximum capacity, operator's weight not included, is 100 kg (the weight of waste).
– In case of fire, use a powder fire extinguisher, not a water one.
– Adjust the operation speed to suit the floor conditions.
– Avoid sudden stops when the machine is going downhill Avoid sharp turns Drive at slow speed
when going downhill
– This machine cannot be used on roads or public streets
– Do not tamper with the machine safety guards
– Follow the routine maintenance procedures scrupulously
– Do not allow any object to enter into the openings Do not use the machine if the openings are
clogged. Always keep the openings free from dust, hairs and any other foreign material which
could reduce the air flow.
– (Only for versions equipped with DustGuard™ system) Pay attention during machine trans-
portation when temperature is below freezing point The water in the tank or in the hoses could
freeze and seriously damage the machine
– Do not remove or modify the plates affixed to the machine.
– When the machine is to be pushed for service reasons (lack of fuel, engine break-down, etc.), the
speed must not exceed 4 km/h
– In case of machine malfunctions, ensure that these are not due to lack of maintenance. If neces-
sary, request assistance from the authorised personnel or from an authorised Service Center.
– If parts must be replaced, require ORIGINAL spare parts from an Authorised Dealer or Retailer.
– To ensure machine proper and safe operation, the scheduled maintenance shown in the relevant
chapter of this Manual, must be performed by the authorised personnel or by an authorised Ser-
vice Center
– (For WET batteries only). When lead batteries (WET) are installed on this machine, do not tilt
the machine more than 30° from its horizontal position to prevent the highly corrosive acid to
leak out of the batteries. If the machine must be tilted to perform any maintenance procedure,
remove the batteries
– The machine must be disposed of properly, because of the presence of toxic-harmful materials
(batteries, oils, etc.), which are subject to standards that require disposal in special centres (see
the User Manual)
(For Floortec R 870 Petrol/LPG)
– While the engine is running, the silencer warms up; do not touch the silencer when it is hot to
avoid burns or fires.
– Running the engine with an insufficient quantity of oil can seriously damage the engine. Check
the oil level with the engine off and the machine on a level surface
– Never run the engine if the air filter is not installed, because the engine could be damaged.
– Technical service procedures on the engine must be performed by an authorised Dealer
– Only use original spare parts or parts of matching quality for the engine Using spare parts of
lower quality can seriously damage the engine
– See also the SAFETY RULES in the Engine Manual, which is to be considered an integral part of
this Manual
(For Floortec R 870 Battery)
– Before using the battery charger, ensure that frequency and voltage values, shown on the ma-
chine serial number plate, match the electrical mains voltage.
– Do not pull or carry the machine by the battery charger cable and never use the battery charger
cable as a handle. Do not close a door on the battery charger cable, or pull the battery charger
cable around sharp edges or corners Do not run the machine on the battery charger cable
– Keep the battery charger cable away from heated surfaces
General Information
10