Suzuki GSF650A Service Manual page 74

1-iv Table of Contents
Repair Instructions ..............................................1H-3
Ignition Coil / Plug Cap and Spark Plug
Removal and Installation...................................1H-3
Spark Plug Inspection and Cleaning ...................1H-4
Ignition Coil / Plug Cap Inspection ......................1H-4
CKP Sensor Inspection .......................................1H-6
CKP Sensor Removal and Installation ................1H-7
Engine Stop Switch Inspection............................1H-7
Ignition Switch Inspection....................................1H-7
Ignition Switch Removal and Installation.............1H-7
Specifications.......................................................1H-9
Service Data........................................................1H-9
Tightening Torque Specifications........................1H-9
Special Tools and Equipment .............................1H-9
Special Tool ........................................................1H-9
Starting System ......................................... 1I-1
Schematic and Routing Diagram......................... 1I-1
Starting System Diagram ..................................... 1I-1
Component Location ............................................ 1I-1
Starting System Components Location................ 1I-1
Diagnostic Information and Procedures............. 1I-1
Starting System Symptom Diagnosis................... 1I-1
Starter motor will not run ...................................... 1I-2
Starter Motor Runs but Does not Crank the
Engine ................................................................ 1I-2
Repair Instructions ............................................... 1I-3
Starter Motor Components................................... 1I-3
Starter Motor Removal and Installation................ 1I-4
Starter Motor Disassembly and Assembly ........... 1I-4
Starter Motor Inspection....................................... 1I-5
Starter Relay Removal and Installation................ 1I-6
Starter Relay Inspection....................................... 1I-7
Turn Signal / Side-stand Relay Removal and
Installation .......................................................... 1I-7
Side-stand / Ignition Interlock System Parts
Inspection........................................................... 1I-8
Starter Clutch Removal and Installation............. 1I-10
Starter Clutch Inspection.................................... 1I-11
Starter Button Inspection.................................... 1I-12
Specifications...................................................... 1I-12
Service Data....................................................... 1I-12
Tightening Torque Specifications....................... 1I-12
Special Tools and Equipment ............................ 1I-13
Recommended Service Material ........................ 1I-13
Special Tool ....................................................... 1I-13
Charging System ...................................... 1J-1
Schematic and Routing Diagram ........................ 1J-1
Charging System Diagram .................................. 1J-1
Component Location ........................................... 1J-1
Charging System Components Location............. 1J-1
Diagnostic Information and Procedures ............ 1J-1
Charging System Symptom Diagnosis................ 1J-1
Battery Runs Down Quickly ................................ 1J-2
Repair Instructions .............................................. 1J-3
Battery Current Leakage Inspection.................... 1J-3
Regulated Voltage Inspection ............................. 1J-3
Generator Inspection........................................... 1J-3
Generator Removal and Installation.................... 1J-4
Regulator / Rectifier Construction ....................... 1J-8
Regulator / Rectifier Inspection ........................... 1J-8
Battery Components ........................................... 1J-9
Battery Charging ................................................. 1J-9
Battery Removal and Installation ...................... 1J-12
Battery Visual Inspection................................... 1J-12
Specifications ..................................................... 1J-13
Service Data...................................................... 1J-13
Tightening Torque Specifications...................... 1J-13
Special Tools and Equipment ........................... 1J-13
Recommended Service Material ....................... 1J-13
Special Tool ...................................................... 1J-14
Exhaust System....................................... 1K-1
Precautions...........................................................1K-1
Precautions for Exhaust System .........................1K-1
Repair Instructions ..............................................1K-2
Exhaust System Construction .............................1K-2
Exhaust Pipe / Muffler Removal and
Installation .........................................................1K-3
Exhaust System Inspection .................................1K-5
Specifications .......................................................1K-6
Tightening Torque Specifications........................1K-6
Special Tools and Equipment .............................1K-6
Recommended Service Material .........................1K-6