Suzuki Intruder VZ1500 Service Manual page 37

4) Inspect the fuel feed hose for damage and fuel
leakage. If any defects are found, the fuel feed hose
must be replaced.
5) After finishing the fuel feed hose inspection, reinstall
the removed parts.
Evaporative Emission Control System
Inspection (E-33 Only)
Inspect evaporative emission control system
Every 12 000 km (7 500 miles, 24 months)
Inspect the evaporative emission control system
periodically (E-33 only).
Engine Oil and Filter Replacement
Replace engine oil
Initially at 1 000 km (600 miles, 2 months) and every
6 000 km (4 000 miles, 12 months) thereafter
Replace oil filter
Initially at 1 000 km (600 miles, 2 months) and every
18 000 km (11 000 miles, 36 months) thereafter
Oil should be changed while the engine is warm. Oil filter
replacement at the above intervals, should be done
together with the engine oil change.
Engine Oil Replacement
1) Keep the motorcycle upright with a jack or wooden
block.
2) Place an oil pan below the engine, and drain engine
oil by removing the oil drain plug (1) and filler cap
(2).
I940H1020074-01
B940H20206008
B940H20206009
1
I940H1020020-01
Maintenance and Lubrication:
3) Tighten the oil drain plug (1) to the specified torque.
CAUTION
!
Replace the gasket washers with new one.
Tightening torque
Oil drain plug (a): 23 N·m (2.3 kgf-m, 16.5 lbf-ft)
4) Pour new oil through the oil filler hole. When
performing an oil change (without oil filter
replacement), the engine will hold about 3.0 L (3.2/
2.6 US/lmp qt) of oil. Use of SF/SG or SH/SJ in API
with MA in JASO.
5) Start up the engine and allow it to run for about 15
minutes at idling speed.
6) Turn off the engine and wait about three minutes,
then check the oil level on the dipstick (2). The oil
level should be between the low level line "A" and full
level line "B". If the oil level is lower than the low level
line "A", add oil to the full level line "B".
2
0B-8
2
I940H1020021-01
1
(a)
I940H1020022-01
"B"
"A"
I822H1020030-01