Page 1 Use, dissemination, distribution or reproduction of this document by unauthorized personnel is not permitted and may be unlawful. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1...
Page 2 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 3 Added digitizer sub-types 110, 200 and 210 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 4 Glossary DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 5 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 6: About This Manual
Figure 1 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 7 For CR 12-X, CR Advanced Reader: ≥ NX 2.0.8800/3.0.8800 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 8 This page is intentionally left blank to enable print out of even and odd pages on duplex printers.
Page 9 This Generic Safety Directions document comprises the general safety relevant information including relevant environmental and occupational safety instructions for the Service Engineer. It is valid for all Agfa HealthCare Imaging Products and part of each Service Documentation as well as Installation Planning document.
Page 10 Improper operation or service activities may cause damage or injuries. INSTRUCTION: Read the "Generic Safety Directions" document (see MEDNET GSO => General Info => Agfa HealthCare => Publications => Service Manual) prior to attempting any operation, repair or maintenance task on the equipment.
Page 11: Table Of Contents
SAFETY DIRECTIONS FOR REMOTE SERVICE ACTIVITIES ......26 DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 Generic Safety Directions for HealthCare Imaging Products Page 3 of 07-2009 Agfa Company Confidential...
Page 12 ERASING PROTECTED HEALTH INFORMATION (PHI) ........28 DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 Generic Safety Directions for HealthCare Imaging Products Page 4 of 07-2009 Agfa Company Confidential...
Page 13: Disclaimer
Fitters, engineers and other persons who are not employed by or otherwise directly affiliated with or authorized by Agfa HealthCare or one of its affiliates are directed to contact one of the local offices of Agfa HealthCare or one of its affiliates before attempting installation or service procedures.
Page 14: Used Icons
Is additional information without influence on the action or step! DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 Generic Safety Directions for HealthCare Imaging Products Page 6 of 07-2009 Agfa Company Confidential...
Page 15: Labels
C&W _005.cdr DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 Generic Safety Directions for HealthCare Imaging Products Page 7 of 07-2009 Agfa Company Confidential...
Page 16: System Labels Concerning Laser Radiation
CLASS 2 LASER PRODUCT conditions. DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 Generic Safety Directions for HealthCare Imaging Products Page 8 of 07-2009 Agfa Company Confidential...
Page 17 CLASS 4 LASER PRODUCT DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 Generic Safety Directions for HealthCare Imaging Products Page 9 of 07-2009 Agfa Company Confidential...
Page 18: Product Complaints
Agfa HealthCare must be notified immediately by telephone, fax or written correspondence to the following address: Agfa Service Support - local support addresses and phone numbers listed on: www.agfa.com Agfa – Gevaert N.V.
Page 19: Intended Use
DD+DIS238.06E Generic Safety Directions Intended Use This Agfa HealthCare product should only be operated in a hospital or clinical radiological environment by qualified staff. It must only be operated according to its specifications and its intended use. Any operation not corresponding to the specifications or intended use may result in hazards, which in turn may lead to serious injuries or fatal accidents (for example electric shocks).
Page 20: Environmental And Occupational Safety Instructions
Is obligated to adhere strictly to regulations and instructions. • Shall familiarise himself or herself with the provisions of the Agfa Healthcare Health, Safety and Environment Policy and any specific rules or procedures relating to occupational safety at work and the protection of the environment.
Page 21: Connections To Other Equipment
Changes or additions to the equipment must only be carried out by persons authorized to do so by Agfa HealthCare. Such changes must comply with best engineering practice and all applicable laws and regulations that have the force of law within the jurisdiction of the hospital.
Page 22: Accessories And Spare Parts
• Use only tools and measuring instruments which are suitable for the procedure. • Only approved Agfa HealthCare accessories must be used. For a list of compatible accessories contact your local Agfa HealthCare organization or www.agfa.com. Compliance Directive for HealthCare Imaging Products:...
Page 23 It is a multilateral agreement among participating countries and certification organizations. Agfa has produced a CB test report and claims national certification in all other member countries of the CB Scheme.
Page 24 DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 Generic Safety Directions for HealthCare Imaging Products Page 16 of 07-2009 Agfa Company Confidential...
Page 25: Safety Directions For Operation
Accessibility of the mains power switch: CAUTION: Do not obstruct the mains power switch. Position the Agfa HealthCare product so that it is possible to disconnect the mains power connection. • Under certain conditions the Agfa HealthCare product will show a display containing a message.
Page 26: Radiation Protection
Disconnect the power supply from the equipment prior to cleaning the equipment. DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 Generic Safety Directions for HealthCare Imaging Products Page 18 of 07-2009 Agfa Company Confidential...
Page 27: General Safety Directions For Service Activities
If "Loctite" has to be used to secure screws, this is stated in the text. • Any Agfa service PC or tool which is to be connected via RS232, RJ45, USB or other interface to an Agfa device must not be connected to the mains but must be operated on its internal battery or indirect supply (low voltage).
Page 28: Safety Directions For Installation Planning Activities
Electrical device. Shock possible. INSTRUCTION: • Do not position Agfa EQUIPMENT so it is difficult to operate the disconnection device when an APPLIANCE COUPLER or separable plug is used as isolation. • Local and International wiring regulations must be observed. Check all supplies and voltages, currents, trips and fuses with the Hospital facilities department or their engineers.
Page 29 Hospital management is responsible for the position, location and fixing of all equipment. DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 Generic Safety Directions for HealthCare Imaging Products Page 21 of 07-2009 Agfa Company Confidential...
Page 30: Safety Directions For Installation Activities
If not otherwise stated, installation and configuration is performed by Agfa HealthCare trained personnel. • If damage of the package is visible from the outside contact your local AGFA representative. • Apart from wearing the required protective clothing, e.g. safety boots and gloves, care must be taken that heavy loads are correctly lifted/carried to avoid injury.
Page 31: Safety Directions For Maintenance And Repair Activities
Safety Directions for Maintenance and Repair Activities • This Technical Documentation identifies the parts on which preventive inspection and maintenance shall be performed by Agfa HealthCare service personnel, including the periods to be applied. • In general the device has to be switched off during service activities. Exception: If the device is switched on to perform tests pay particular attention to any hazards due to moving and rotating parts.
Page 32 NOTE: On MedNet, GSO Library path "General Info => Agfa HealthCare => Publications => Service Manual" a form “IEC 62353:2007 Test Documentation” for CR Digitizers is available, to be handed out to the responsible organization...
Page 33 When cleaning optical elements follow the service manual precisely. DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 Generic Safety Directions for HealthCare Imaging Products Page 25 of 07-2009 Agfa Company Confidential...
Page 34: Safety Directions For Remote Service Activities
DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 Generic Safety Directions for HealthCare Imaging Products Page 26 of 07-2009 Agfa Company Confidential...
Page 35: Safety Directions For Transport And Shipment Of Spare Parts, Accessories And Devices
The Recycling Passports are meant to be used as information for waste treatment partners and companies that want to recycle end-of-life Agfa equipment. To get a copy of the required Agfa HealthCare Recycling Passport please contact your local Sales organization.
Page 36: Waste Disposal
For more detailed information about take-back and recycling of this product, please contact your local Agfa service organization. By ensuring this product is disposed of correctly, you will help prevent potential negative consequences for the environment and human health, which could otherwise be caused by inappropriate waste handling of this product.
Page 37 DD+DIS300.12E NX 2.0.8800 / 3.0.8800 Service Manual DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 03-2013 Printed in Germany Document Node ID: 33998941...
Page 38 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 39 INSTALLATION CHECKLIST ....................47 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 40: Introduction
Check the shipment completeness. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 41: Checking Installation Site Prerequisites
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 42: Unpacking The Nx Workstation And Monitor
In case the delivery is not complete, escalate to the next support level. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4...
Page 43: Performing The Installation Steps As Described In The Quick Installation Guide
Figure 3 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 44 Figure 4 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 45 ** CR 12-X, subtype 200 or CR Advanced Reader, subtype 210 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 46: Finalizing The Installation
Inform the customer about the digitizer system. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 47: Adding Windows And Nx Users
Figure 6 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 48 Add NX users and roles. For an example see Figure 8 and Figure 9. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4...
Page 49 Figure 8 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 50 Figure 9 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 51: If Required: Configuring Digitizer And Nx For The Local Network
Figure 10 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 52 Figure 13 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 53: Setup Of Connectivity To Additional System Components
Installation". DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 54: Checking Software Version
Usage of plates and cassettes, see section 4.8.2. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 55: Training For Operating The Digitizer
Document ID 39248556. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 56: Training For Usage Of Plates And Cassettes
User Manual. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 57: Appendix: Installation Of The Digitizer Without Using The Cr 10-X / Cr 12-X Configuration Wizard
4, Installation. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 58: Installation Preparation
Figure 18 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 59: Performing Setup Of The Nx Workstation
Figure 20 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 60: Control Panel
Figure 23 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 61 Figure 25 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 62 Figure 27 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 63 Figure 29 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 64 Figure 31 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 65 Figure 33 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 66 Figure 35 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 67 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 68 Figure 40 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 69 Figure 43 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 70 Figure 45 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 71 3216 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 72 Figure 50 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 73 ** Use CR 12-X for subtype 200 or CR Advanced Reader, subtype 210 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4...
Page 74 Figure 53 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 75 Document ID 39248556. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 76 Figure 56 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 77 Figure 59 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 78 The digitizer status LED changes from red to green. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 79: Verifying The Installation
Figure 62 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 80 Figure 65 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 81: Performing The Installation Wizard Of The Digitizer
Figure 67 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 82: Performing A Backup
Finalize the installation. For details refer to section 4. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 83: Installation Checklist
ASC = Configuration & Customization DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 4 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 84 This page is intentionally left blank to enable print out of even and odd pages on duplex printers.
Page 85 Document Title Not applicable DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 03-2013 printed in Germany Document Node ID: 33999201...
Page 86 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 2 of 19...
Page 87 Scanning the Image Plate.......................18 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 3 of 19...
Page 88: The Digitizer System In A Nutshell
Example for such a workstation: Agfa SE 2.0 Standalone. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 4 of 19...
Page 89: Differences Between Digitizer Subtypes 100, 110, 200 And 210
All application requiring 50 μm resolution, e.g. Mammography. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 5 of 19...
Page 90: Main Components Of The Digitizer
Figure 4 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 6 of 19...
Page 91: Main Components Of The Cassette With Image Plate
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 7 of 19...
Page 92: Main Functions Of The Nx Workstation
For more information refer to the NX workstation service manual. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 8 of 19...
Page 93: Workflow Of The Digitizer System
Figure 7 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 9 of 19...
Page 94: Hardware Components Of The Digitizer
Detects the image plate approx. 24 cm after begin of scan. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 10 of 19...
Page 95 *E-Label: Small memory module keeping device or module specific data. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 11 of 19...
Page 96: Boot-Up Of The Digitizer
Figure 10 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 12 of 19...
Page 97 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 13 of 19...
Page 98: Description Of The Image Plate Run
Figure 11 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 14 of 19...
Page 99: Image Plate Run Details
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 15 of 19...
Page 100 Figure 13 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 16 of 19...
Page 101 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 17 of 19...
Page 102 Figure 14 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 18 of 19...
Page 103 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 2 / Page 19 of 19...
Page 104 This page is intentionally left blank to enable print out of even and odd pages on duplex printers.
Page 105 Document Title Not applicable DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 03-2013 Printed in Germany Document Node ID: 33998032...
Page 106 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.1 / Page 2 of 11...
Page 107 Safety Notes when working at the Drawer Unit ..............11 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.1 / Page 3 of 11...
Page 108: Intended Use
For the meaning of the different labels refer to the user manual. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.1 / Page 4 of 11...
Page 109: Labels Inside The Digitizer
Figure 2 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.1 / Page 5 of 11...
Page 110: Safety Notes For Service Activities
Source (UPS) as the PC. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.1 / Page 6 of 11...
Page 111: Safety Notes For Installation
Use proper foot and hand protection when lifting the digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.1 / Page 7 of 11...
Page 112: Safety Notes For Mobile Application
Figure 3 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.1 / Page 8 of 11...
Page 113: Safety Notes For Corrective Maintenance Work
Handle the light collector with great care. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.1 / Page 9 of 11...
Page 114: Safety Notes When Working At The Slow Scan Drum
Handle the Slow Scan Drum carefully. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.1 / Page 10 of 11...
Page 115: Safety Notes When Working At The Drawer Unit
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.1 / Page 11 of 11...
Page 116 This page is intentionally left blank to enable print out of even and odd pages on duplex printers.
Page 117 CR 10-X / CR 12-X Service Manual, Chapter 3.6 - Adjustments and Calibrations DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 03-2013 Printed in Germany...
Page 118 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 2 of 31...
Page 119 Shading Calibration.........................26 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 3 of 31...
Page 120 REMOTE SERVICE........................30 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 4 of 31...
Page 121 When ordering, the actual revision of the spare part is delivered. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 5 of 31...
Page 122: Digitizer Service User Interface
Close the browser window. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 6 of 31...
Page 123: Logout
*Menu “Clear Image Queue” available as of software ARC_1404 only. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 7 of 31...
Page 124: General Info
Figure 4 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 8 of 31...
Page 125: Network Info
Figure 5 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 9 of 31...
Page 126: Reporting
Figure 6 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 10 of 31...
Page 127: Error Statistics
See section 2.5.1. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 11 of 31...
Page 128: Service Activity Logfile
The “ServiceActivity.log” file is part of the backup. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 12 of 31...
Page 129: Install & Configure
Figure 9 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 13 of 31...
Page 130 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 14 of 31...
Page 131 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 15 of 31...
Page 132 Figure 12 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 16 of 31...
Page 133: Digitizer Settings
Follow the further instructions. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 17 of 31...
Page 134: Error Viewer Installation
The error viewer installation is also part of the installation procedure of the digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 18 of 31...
Page 135: Log Settings
Extended logging reduces the performance of the system. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 19 of 31...
Page 136: Diagnose & Repair
*Also the internal error code (in this example "25613") can be looked up. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 20 of 31...
Page 137: Device Test
Figure 17 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 21 of 31...
Page 138 A gray displayed rectangle shows the next possible action. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 22 of 31...
Page 139: Endurance Run Cycle
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 23 of 31...
Page 140: Pmt High Voltage On/Off
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 24 of 31...
Page 141: Reset Relative Counters
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 25 of 31...
Page 142: Maintain & Calibrate
Select link: <Download calibration line> DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 26 of 31...
Page 143 Figure 24 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 27 of 31...
Page 144: Backup / Restore
It is recommended to perform in any case a "complete backup". DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 28 of 31...
Page 145: Restore
Figure 26 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 29 of 31...
Page 146: Remote Service
Endurance Run Cycle DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 30 of 31...
Page 147 *Scanning blocked during error viewer installation as of software > ARC_1404. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.2 / Page 31 of 31...
Page 148 This page is intentionally left blank to enable print out of even and odd pages on duplex printers.
Page 149 Referenced documents are listed in the respective sections. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 03-2013 Printed in Germany...
Page 150 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 2 of 46...
Page 151 APPENDIX: ERROR CODES....................17 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 3 of 46...
Page 152: General Symptom Classification
** triple red blinking means: approx. 3 on/off cycles per second followed by 1 second off DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 4 of 46...
Page 153: Faults With Error Codes
ARC_1404. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 5 of 46...
Page 154: No Error Code - Status Led Is Off Or Slow Red Blinking
Solution 3 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 6 of 46...
Page 155 Switch on the digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 7 of 46...
Page 156: No Error Code - Status Led Fast Red Blinking
For an example of file ErrorInformation.html see page 9. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 8 of 46...
Page 157 Figure 2: Example for file ErrorInformation.html DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 9 of 46...
Page 158: No Error Code - Status Led Triple Red Blinking
For an example of file ErrorInformation.html see page 9. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 10 of 46...
Page 159 (see table below): DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 11 of 46...
Page 160 Wait until the boot-up is finished (approximately 1 minute). DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 12 of 46...
Page 161: Image Faults Parallel To Image Plate Run
Solution DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 13 of 46...
Page 162: Dust Stripes
If unacceptable image flaws suntil occur: Escalate to the next support level. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 14 of 46...
Page 163: Image Faults Vertical To Image Plate Run
Escalate to the next support level. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 15 of 46...
Page 164: Appendix: Using The Limit Pattern To Judge Image Flaws
If there are unacceptable effects see sections 6 and 7 of this document. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 16 of 46...
Page 165: Appendix: Error Codes
4200 Slow Scan Correction DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 17 of 46...
Page 166 Cure 2: Open Digitizer and remove jammed IP. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 18 of 46...
Page 167 Unit' has to be replaced. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 19 of 46...
Page 168 'Cassette Unit' has to be replaced. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 20 of 46...
Page 169 'Cassette Unit' has to be replaced. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 21 of 46...
Page 170 Cure 6: Replace 'Power Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 22 of 46...
Page 171 Cure 6: Replace 'Optic Module'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 23 of 46...
Page 172 Cure 2: Replace 'Optic Module'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 24 of 46...
Page 173 Cure 2: Perform a shading calibration. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 25 of 46...
Page 174 Cure 3: Replace 'PMI Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 26 of 46...
Page 175 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 27 of 46...
Page 176 Cure 2: Check 'Power Board' and replace if defective. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 28 of 46...
Page 177 Cure 3: Replace 'Power Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 29 of 46...
Page 178 Cure 4: Replace 'Power Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 30 of 46...
Page 179 Cure 3: Replace 'Power Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 31 of 46...
Page 180 Check time setting via service tool at item Digitizer-Settings in the webbrowser. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 32 of 46...
Page 181 Cure 2: Replace 'PMI Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 33 of 46...
Page 182 Restart digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 34 of 46...
Page 183 Digitizer software with option format. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 35 of 46...
Page 184 Cure 3: Replace Digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 36 of 46...
Page 185 Cure 7: Update software of digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 37 of 46...
Page 186 Cure 1: Clear IP jam manually. Install the newest digitizer software. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 38 of 46...
Page 187 Install the newest digitizer software. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 39 of 46...
Page 188 Cure 6: Update software of digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 40 of 46...
Page 189 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 41 of 46...
Page 190 Cure 6: Check configuration of Image Processing Station and Digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 42 of 46...
Page 191 (network addresses and names, AE titles, ports). DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 43 of 46...
Page 192 (network addresses and names, AE titles, ports). DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 44 of 46...
Page 193 Replace 'Slow Scan Plate with Belt Tensioner'. Replace 'Slow Scan Belt'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 45 of 46...
Page 194 Replace 'Slow Scan Plate with Belt Tensioner'. Replace 'Slow Scan Belt'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.3 / 46 of 46...
Page 195 Document Title Not applicable DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 03-2013 Printed in Germany Document Node ID: 33998033...
Page 196 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.4 / Page 2 of 7...
Page 197 STATUS INDICATOR ON THE USER INTERFACE BOARD ..........7 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.4 / Page 3 of 7...
Page 198 Reset Hardware. For R&D purposes only. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.4 / Page 4 of 7...
Page 199 ** On only if there is ethernet traffic DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.4 / Page 5 of 7...
Page 200 Board reset. Only for R&D purpose. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.4 / Page 6 of 7...
Page 201 1 sec. off) DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.4 / Page 7 of 7...
Page 202 This page is intentionally left blank to enable print out of even and odd pages on duplex printers.
Page 203 03-2013 Added subtypes 110, 200 and 210. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library Any printed copy of this document is uncontrolled. Edition 1, Revision 1 03-2013 printed in Germany Document Node ID: 34164176...
Page 204 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.5 / Page 2 of 2...
Page 205 Document Title None DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 03-2013 printed in Germany Document Node ID: 33998938 eq_03-6_adjustments_e_template_v07 Agfa Company Confidential Copyright ©...
Page 206 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.6 / Page 2 of 10...
Page 207 Appendix: Possible Reasons for a failed Shading Calibration..........10 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.6 / Page 3 of 10...
Page 208: Overview Of Adjustments And Calibrations
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.6 / Page 4 of 10...
Page 209: Shading Calibration
Erase the IP. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.6 / Page 5 of 10...
Page 210: Exposing The Cassette
Remove the Cu-filter from the X-ray device. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.6 / Page 6 of 10...
Page 211: Scanning The Image Plate
Figure 3 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.6 / Page 7 of 10...
Page 212 - too low pixel values …) refer to section 2.5 for possible remedies. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.6 / Page 8 of 10...
Page 213: Verifying A Successful Shading Calibration
Result DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.6 / Page 9 of 10...
Page 214: Appendix: Possible Reasons For A Failed Shading Calibration
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 3.6 / Page 10 of 10...
Page 215 DD+DIS048.13E Service Bulletin No. 10, Software ARC_1404 available DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 04-2013 Printed in Germany...
Page 216 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.8 / Page 2 of 13...
Page 217 New Features of Software ARC_1404..................12 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.8 / Page 3 of 13...
Page 218: Software Release Arc_1103
In some cases wrong or incomplete error messages are displayed. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.8 / Page 4 of 13...
Page 219: Software Release Arc_1201
Reliability of the barcode reading improved. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.8 / Page 5 of 13...
Page 220: Known Software Issues Of Software Arc_1201
It remains on "feeding IP". DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.8 / Page 6 of 13...
Page 221: Software Release Arc_1202
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.8 / Page 7 of 13...
Page 222: Software Release Arc_1302
“feeding IP”, despite endurance run worked fine. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.8 / Page 8 of 13...
Page 223: New Features Of Software Arc_1302
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.8 / Page 9 of 13...
Page 224: Software Release Arc_1304
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.8 / Page 10 of 13...
Page 225: Software Release Arc_1404
110, 200 and 210 that were introduced in 04-2013. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.8 / Page 11 of 13...
Page 226: Solved Software Issues In Software Arc_1404
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.8 / Page 12 of 13...
Page 227 Light Collector are now working correctly. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 3 CR 10-X / CR Reader / CR 12-X / CR Advanced ReaderChapter 3.8 / Page 13 of 13...
Page 228 This page is intentionally left blank to enable print out of even and odd pages on duplex printers.
Page 229 Document Title Not applicable DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 03-2013 Printed in Germany Document Node ID: 34000493...
Page 230 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 231 Slow Scan Belt DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 232 On the following pages the circuit diagrams of the digitizer are attached. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1...
Page 233 & $ WR $30, %8 6FDQQLQJ$ $ $&/ 67 3 3RZHU 6XSSO\ 9'& 9 ) $&1 $7 $ %8 67 ) ,3 '(7(&7 6 /RJ 'HEXJ ) 9 5HVB0LUU % ) 67 $32:(5 $7...
Page 234 & $ 67 2SWLF0RGXOH$ WR $237,&63RZHU IURP $3RZHU $ %8 67 +DQGOLQJ) $ (/DEHO 67 %8 9B307B,) $GGU ) P$) ) 9B307B,) ) % P$) 9B7XEH ) P$) 30,%G 3 )...
Page 235 & %8 $*$/92&211(&7 IURP $30, H/DEHO $ $ $ %8 67 67 6FDQQLQJ) % $237,&632:(5 $ % $/'02'8/$725 $ 67 67 $ *DOYR 9ROWDJH % P$) 7RS YLHZ $/'02'8/$725 $237,&632:(5 67 67 $...
Page 236 This page is intentionally left blank to enable print out of even and odd pages on duplex printers.
Page 237 Use, dissemination, distribution or reproduction of this document by unauthorized personnel is not permitted and may be unlawful. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Document Node ID: 33979680...
Page 238 Completeness" in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X...
Page 239 Worldwide: Returns@matrium.net DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X Chapter 5 / Page 3 of 14...
Page 240 CASSETTE CR MD1.0 PAGES 12 - 13 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X...
Page 241 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X...
Page 242 5151_CHAP05_01_M.CDR COVER DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X Chapter 5 / Page 6 of 14...
Page 243 99 = Spare Part is not shown in Exploded Views. COVER DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X...
Page 244 5151_chap05_02_m.cdr ELECTRICS AND CABLES DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X Chapter 5 / Page 8 of 14...
Page 245 99 = Spare Part is not shown in Exploded Views. ELECTRICS AND CABLES DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X...
Page 246 5151_CHAP05_03_M.CDR HANDLING AND SCANNING DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X Chapter 5 / Page 10 of 14...
Page 247 99 = Spare Part is not shown in Exploded Views. HANDLING AND SCANNING DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X...
Page 248 5151_CHAP05_04_M.CDR CASSETTE CR MD1.0 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X Chapter 5 / Page 12 of 14...
Page 249 99 = Spare Part is not shown in Exploded Views. CASSETTE CR MD1.0 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X...
Page 250 CASSETTE CR MD 1.0 5R3JY DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR 12-X Chapter 5 / Page 14 of 14...
Page 251 03-2013 Added subtypes 110, 200 and 210. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library Any printed copy of this document is uncontrolled. Edition 1, Revision 1 03-2013 printed in Germany Document Node ID: 33998305...
Page 252 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 253 * For external partners: Please ask your local Agfa representative for access. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1...
Page 254 This page is intentionally left blank to enable print out of even and odd pages on duplex printers. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1...
Page 255 Use, dissemination, distribution or reproduction of this document by unauthorized personnel is not permitted and may be unlawful. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1...
Page 256 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 2 of 24...
Page 257 Not applicable DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 3 of 24...
Page 258 SPECIFICATIONS........................19 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 4 of 24...
Page 259 Installation Readiness Checklist .....................24 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 5 of 24...
Page 260: Product Description
Figure 2 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 6 of 24...
Page 261: Workflow Of A Digitizer System
Figure 3 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 7 of 24...
Page 262: Scope Of Delivery And Accessories
For detailed specifications refer to section 6, Electrical Connections. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 8 of 24...
Page 263: Accessories
Delivery  SRSS> DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 9 of 24...
Page 264: Installation Site Size Requirements
Figure 5 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 10 of 24...
Page 265: Guidelines For Placing The Digitizer
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 11 of 24...
Page 266: System Integration
* Only required if a network gateway is used on site. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 12 of 24...
Page 267: Ambient Conditions During Transport, Storage And Operation
2500 Lux. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 13 of 24...
Page 268: X-Ray Radiation Conditions
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 14 of 24...
Page 269: Electrical Connections At The Digitizer
Earthed contact outlet for the NEMA 5-15 P plug DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 15 of 24...
Page 270: Network Connection In The Installation Room
NEMA 6-15P - SJT, 3 x AWG 18 with IEC C13 connector (female); Hospital grade (HG) DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1...
Page 271: Electrical Connections Of The Optional Ups
Figure 10 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 17 of 24...
Page 272: Digitizer Dimensions And Weight
(kg / lb) DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 18 of 24...
Page 273: Specifications
USA max. 15 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 19 of 24...
Page 274: Functional Data Of The Optional Ups
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 20 of 24...
Page 275: Interface Data
* EMC = Electromagnetic Compatibility DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 21 of 24...
Page 276 Agfa system without additional protective measures. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 22 of 24...
Page 277: Installation Planning Checklist
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 23 of 24...
Page 278: Installation Readiness Checklist
Signature of Field Service Engineer: ___________________________________ DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader Chapter 11 / Page 24 of 24...
Page 279 Document Title Not applicable DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 03-2013 Printed in Germany Document Node ID: 34000615...
Page 280 Completeness” in the Agfa HealthCare Library. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 281 TCP/IP network. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 282 Cable to connect to a computer network. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 1 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader...
Page 283 CR 10-X / CR 12-X Type 5151 / 100 / 110 / 200 / 210 1st Edition...
Page 284 Version 1.1 06-2008 Added how to integrate the order list for documentation in a printed manual. See section 1. Edition 1, Revision 2 06-2008 printed in Germany Document Node ID: 16099429 Agfa Company Confidential Copyright © 2008 Agfa HealthCare N.V.
Page 285 It is recommended to print these pages separately on a DIN A3 or ANSI B (Ledger) printer. DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 2 of 5 06-2008 Agfa Company Confidential...
Page 286 Figure 2: Print dialogue for printing single pages or chapters DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 3 of 5 06-2008 Agfa Company Confidential...
Page 287 This allows adding comments, to highlight or underline text and many more text manipulations. Figure 4: Adobe Reader comments toolbar DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 4 of 5 06-2008 Agfa Company Confidential...
Page 288 DOCUMENT CONTROL NOTE: The controlled version of this document resides on MedNet. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 5 of 5 06-2008 Agfa Company Confidential...

This manual is also suitable for:

Cr 10-x Cr reader Cr 12-x Cr advanced reader

AGFA CR Series Service Manual

Table of Contents

Table of Contents

1 Introduction

2 Installation Preparation

3 Performing the Installation Steps as Described in the Quick Installation Guide

4 Finalizing the Installation

5 Appendix: Installation of the Digitizer Without Using the CR 10-X / CR 12-X Configuration Wizard

6 Installation Checklist

Table of Contents

1 The Digitizer System in a Nutshell

2 Workflow of the Digitizer System

3 Hardware Components of the Digitizer

4 Boot-Up of the Digitizer

5 Description of the Image Plate Run

Table of Contents

1 Intended Use

2 Labels in and on the Device

3 Safety Notes for Service Activities

Digitizer Service User Interface

2 Digitizer Service User Interface

3 Remote Service

Table of Contents

1 General Symptom Classification

2 Faults with Error Codes

3 No Error Code - Status Led Is off or Slow Red Blinking

4 No Error Code - Status Led Fast Red Blinking

5 No Error Code - Status Led Triple Red Blinking

6 Image Faults Parallel to Image Plate Run

7 Image Faults Vertical to Image Plate Run

8 Appendix: Using the Limit Pattern to Judge Image Flaws

9 Appendix: Error Codes

Section 7

1 Overview of Adjustments and Calibrations

2 Shading Calibration

Appendix: Possible Reasons for a Failed Shading Calibration

Section 8

1 Software Release Arc_1103

2 Software Release Arc_1201

3 Software Release Arc_1202

4 Software Release Arc_1302

5 Software Release Arc_1304

6 Software Release Arc_1404

Installation Planning

1 Product Description

2 Scope of Delivery and Accessories

3 Installation Site Size Requirements

4 System Integration

5 Ambient Conditions During Transport, Storage and Operation

6 Electrical Connections

7 Digitizer Dimensions and Weight

8 Specifications

9 Safety Standards

10 Installation Planning Checklist

Quick Links

Chapters

Related Manuals for AGFA CR Series

Summary of Contents for AGFA CR Series