Page 1
CR Multiformat Reader Type 5151 / 310 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 02-2014 Printed in Germany Document ID: 42866196...
Page 2
Agfa HealthCare N.V. or one of its affiliates to provide such services. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 2 of 218...
Safety Notes for Installation ....................40 Safety Notes for mobile Application ..................40 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 3 of 218...
Page 4
4.4.5 Finalizing the Workstation Installation ..................67 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 4 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 5
7.5.2 Dust Stripes...........................114 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 5 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 6
9.2.8 Checking the Erasure Unit ....................188 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 6 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 7
10.7.2 Solved software issues with software ARC_2012 ..............208 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 7 of 218...
Page 8
13.2 Power Board / Power II Board ....................218 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 8 of 218...
Additional documents are referenced in the corresponding sections. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 9 of 218...
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 10 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
515100af.cdr Figure 2 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 11 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 12
515100ad.cdr Figure 3 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 12 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
CR15-X -Vxyz Digitizer Model file name on NX DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 13 of 218...
Page 14
**** IP Detection Double Light Sensor is also introduced in subtypes 100 (SN ≥ 5.000), 110 (SN ≥ 20.500), 200 (SN ≥ 30.500) and 210 (SN ≥ 40.500) DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
For more information refer to the NX workstation service manual. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 15 of 218...
515102ca.cdr Figure 5 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 16 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
On the barcode label the expiration date of the image plate is written in human readable letters. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 17 of 218...
515102az.cdr Figure 7 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 18 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
The Digitizer Remote Display and the Status Indicator are explained in the following sub- sections. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 19 of 218...
NX workstation. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 20 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
“350 ms on / 350 ms off” blinking. The color did not change. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Page 22
Digitizer failed. 1 sec. off) DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 22 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 23
Digitizer warning or error information. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 23 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
IP Detection Double Light Sensor Figure 9 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 24 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Supplies power for all consumers. (24 V) DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 25 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 26
Is the interface for a blue LED glued to the Light Collector. This blue LED generates a reference signal for sensitivity correction. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 26 of 218...
Page 27
*E-Label: Small memory module keeping device or module specific data. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 27 of 218...
** IP Drawer Module for subtypes 100, 110, 200 and 210 only. For subtypes 300 and 310 it is named “IP Drawer Module Multiformat” DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 28 of 218...
517502eb.cdr Figure 13 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 29 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 30
517502ec.cdr Figure 14 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 30 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 31
After recognizing begin of scan signal from barcode and a predefined distance the image acquisition starts. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 31 of 218...
Page 32
Figure 15: Top view on IP Drawer Module Multiformat with different IP sizes DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Page 33
Scanning the Image Plate Figure 16 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 33 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 34
After the boot-up it is possible to remove the Cassette. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 34 of 218...
Page 35
Position after scan Figure 17 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 35 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
* time depends on galvo adjustment time. Can be up to 5 minutes. Figure 18 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 36 of 218...
Page 37
Digitizer does not check, whether the NX application is running. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 37 of 218...
Before clearing the image queue, check all other troubleshooting options to get the image transmitted to the destination. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 38 of 218...
Digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 39 of 218...
Use proper foot and hand protection when lifting the Digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 40 of 218...
Expose the light sensitive side of the PMT as little as possible to daylight. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Handle the Slow Scan Drum carefully. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 42 of 218...
Agfa Intranet Agfa Portal via Internet DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 43 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
For an overview of accessories refer to the sales information, which is available in the National Sales Organization. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 44 of 218...
Figure 21 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 45 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 46
The weight of the package is 50 kg (111 lb). DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 46 of 218...
Always connect the associated monitor to the same Uninterruptible Power Source (UPS) as the PC. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 47 of 218...
Page 48
Earthed contact outlet for the NEMA 5-15 P plug DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 48 of 218...
The network connection in the installation room has to comply with IEC 60950. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
* Only required if a network gateway is used on site. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 50 of 218...
Manual DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 51 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Remarks: Signature of Field Service Engineer: ___________________________________ DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 52 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 53 of 218...
If no damage is visible from the outside start installation. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 54 of 218...
Agfa Intranet Agfa Portal via Internet DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 55 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 56
255.255.255.0 Figure 27 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 56 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 57
255.255.255.0 Figure 28 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 57 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 58
192.192.192.193 (fixed) Figure 29 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 58 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Perform further activities depending on local regulations. Inform the customer about the Digitizer system. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 59 of 218...
If required, create additional users with NX operator rights. Figure 30 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 60 of 218...
Page 61
Add NX users and roles. For an example see Figure 32 and Figure 33. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Page 62
Service Manual Figure 32 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 62 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 63
Service Manual Figure 33 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 63 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Entry Figure 34 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 64 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 65
(16) Wait until the 2nd boot-up is finished. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 65 of 218...
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 66 of 218...
Switch on the Maintenance Indicator only, if requested by your Service Manager. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Usage of plates and cassettes, see section 4.6.2. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 68 of 218...
515101zh.cdr Figure 41 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 69 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
For more information refer to the CR Plates and Cassettes (CR MD 1.0 General) User Manual. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 70 of 218...
Possibility 3: Set a fixed IP address for the NX workstation. See NX service manual chapter 4, Installation. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 71 of 218...
Figure 43 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 72 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Figure 45 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 73 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 74
Adapt date and time. Figure 48 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 74 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 75
Select: Properties Figure 50 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 75 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 76
(2 times) Figure 52 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 76 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 77
(15) Select: Change Figure 54 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 77 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 78
(23) Close the tool. Figure 56 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 78 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 79
(26) Click: Change keyboards Figure 58 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 79 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 80
(32) Select: Copy settings.. Figure 60 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 80 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 81
When installing the Digitizer at SE, do not install the Error Viewer. SE has an Error Viewer already pre-installed. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 81 of 218...
Page 82
(48) Close the License Manager. Figure 65 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 82 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 83
Possible problems during activation are logged in the Activation Helper window. Figure 68 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 83 of 218...
Page 84
(57) Select: Load active configuration Figure 70 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 84 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 85
Fast ID - Port number 3216 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 85 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 86
See NOTE next page. Figure 75 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 86 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 87
*** Use CR 15-X for subtype 300 or CR Multiformat Reader, subtype 310 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Page 88
255.255.255.0 Figure 78 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 88 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 89
For more information see also Application Note NX 2.0.8800 / 3.0.8800, Document ID 39248556. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 89 of 218...
Page 90
Configuration Figure 81 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 90 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 91
(76) Select: Import Figure 84 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 91 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Figure 86 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 92 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 93
Any other examination type gives a result which cannot be used for image evaluation. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Page 94
For detailed instructions refer to chapter 3.3, Troubleshooting DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 94 of 218...
Select : Logout Figure 93 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 95 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Regulations 14. Customer Training DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 96 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
REQUIRED TIME: Approximately 30 minutes DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 97 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
5151_c36_001.cdr Figure 94 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 98 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Select Calibrate. Figure 95 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 99 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 100
Digitizer: Scanning starts. Figure 97 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 100 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Identify and scan the image. Use exam type: System diagnosis > Flatfield DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
This is described with each single service activity. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 102 of 218...
*unknown IP address can also be looked up in file ErrorInformation.html on USB flash drive. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
C) Look-up the error in section 7.9 of this document. XXXX represents the software version DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 104 of 218...
See section 3.4, Electrical and mechanical Codes, Fuses, LEDs for the location and meaning of the LEDs. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 105 of 218...
Page 106
Figure 99 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 106 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
For an example of file ErrorInformation.html see page 108. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 107 of 218...
Page 108
13001 Figure 100: Example for file ErrorInformation.html DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 108 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
For an example of file ErrorInformation.html see page 108. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 109 of 218...
Page 110
Solution 4 communication (see table below): DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 110 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 111
Wait until the boot-up is finished (approximately 1 minute). DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 111 of 218...
Page 112
After a reset of the network settings it is required to configure the network settings again. Refer to section 4. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 112 of 218...
Perform a shading calibration. Refer to section 5. Solution DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 113 of 218...
If the dust stripes are still visible: Escalate to the next support level. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Wait until the PMT has back the normal sensitivity (time depends on duration and brightness of the light exposure). DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 115 of 218...
If there are unacceptable effects see sections 7.5 and 7.6 of this document. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
4100 Processing Station 4200 Slow Scan Correction DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 117 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 118
Cure 2: Open Digitizer and remove jammed IP. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 118 of 218...
Page 119
In case of repeated appearance of this failure the 'Cassette Unit' has to be replaced. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 119 of 218...
Page 120
In case of repeated appearance of this failure the 'Cassette Unit' has to be replaced. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 120 of 218...
Page 121
In case of repeated appearance of this failure the 'Cassette Unit' has to be replaced. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 121 of 218...
Page 122
Reason 6: 'Power Board' defective. Cure 6: Replace 'Power Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 122 of 218...
Page 123
Reason 6: 'Optic Module' defective. Cure 6: Replace 'Optic Module'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 123 of 218...
Page 124
Cure 2: Replace 'Optic Module'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 124 of 218...
Page 125
Reason 2: Shading calibration file is corrupt. Cure 2: Perform a shading calibration. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 125 of 218...
Page 126
Reason 3: 'PMI Board' defective. Cure 3: Replace 'PMI Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 126 of 218...
Page 127
Reason 3: 'Power Board' defective. Cure 3: Replace 'Power Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 127 of 218...
Page 128
Cure 4: Check 'Power Board'. Replace if defective. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 128 of 218...
Page 129
Reason 3: 'Power Board' defective. Cure 3: Replace 'Power Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 129 of 218...
Page 130
Reason 4: 'Power Board' defective. Cure 4: Replace 'Power Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 130 of 218...
Page 131
Reason 3: 'Power Board' defective. Cure 3: Replace 'Power Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 131 of 218...
Page 132
Cure 1: Restart digitizer to get detailed selftest result. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 132 of 218...
Page 133
Check time setting via service tool at item Digitizer-Settings in the webbrowser. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 133 of 218...
Page 134
Reason 2: Flash memory on 'PMI Board' is defective. Cure 2: Replace 'PMI Board'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 134 of 218...
Page 135
Cure 2: Protect the digitizer from direct sunlight. Restart digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 135 of 218...
Page 136
Digitizer software with option format. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 136 of 218...
Page 137
Reason 3: The 'Device E-Label' is defective. Cure 3: Replace Digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 137 of 218...
Page 138
Reason 7: Software error at digitizer Cure 7: Update software of digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 138 of 218...
Page 139
Cure 1: Clear IP jam manually. Install the newest digitizer software. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 139 of 218...
Page 140
The image is uncorrected. Cure 5: Install newest software. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 140 of 218...
Page 141
Reason 6: Software error at digitizer Cure 6: Update software of digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 141 of 218...
Page 142
Cure 2: Remove write protection or use an USB flash memory with 10 kBytes free memory left. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 142 of 218...
Page 143
Digitizer software. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 143 of 218...
Page 144
Install the newest digitizer software with option format. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 144 of 218...
Page 145
Reinstall the image processing station software. Use the latest software version. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 145 of 218...
Page 146
Digitizer and destination settings (network addresses and names, AE titles, ports). DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 146 of 218...
Page 147
Replace 'Slow Scan Plate with Belt Tensioner'. Replace 'Slow Scan Belt'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 147 of 218...
Page 148
Replace 'Slow Scan Plate with Belt Tensioner'. Replace 'Slow Scan Belt'. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 148 of 218...
When ordering, the actual revision of the spare part is delivered. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 149 of 218...
For more information se also section 8.2.4, Remote access to the service functions. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Page 151
Do not quit a service session by closing the browser window. Only quit a service session via Logout button. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 151 of 218...
Restore 8.2.3.26 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 152 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Usage Figure 107 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 153 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Network Info Figure 109 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 154 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
07-Nov-2013 16:08:23 Figure 110 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 155 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
PC. Figure 112 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 156 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
11. Figure 113 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 157 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Function “Load default settings” is available as of software version ARC_1404 only. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 158 of 218...
Function “Load default settings” is available as of software version ARC_1404 only. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 159 of 218...
Usage Follow the further instructions. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 160 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 161 of 218...
Figure 119 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 162 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Click: Start Selftest Figure 121 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 163 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Press the grey marked buttons to perform the required actions. See also NOTE below. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 164 of 218...
Page 165
Service Manual Figure 123 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 165 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Click: Confirm Figure 124 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 166 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 167
Digitizer to allow further service activities. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 167 of 218...
By a reset of the Digitizer (switch off / on) the high voltage for the PMT is switched on again. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 168 of 218...
Before clearing the image queue, check all other troubleshooting options to get the image transmitted to the destination. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 169 of 218...
Service Plan for the Digitizer, Document ID 32332049. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 170 of 218...
Page 171
Figure 129: Maintenance Indicator set to “yes” Figure 130: Maintenance Indicator set to “no” DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 171 of 218...
To copy the current calibration curve to PC for troubleshooting purpose: Select: Download calibration line DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 172 of 218...
Page 173
Service Manual Figure 131 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 173 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
It is recommended to perform in any case a "complete backup". DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 174 of 218...
BAC_CR15-5151_<Serial Number>DDMMMYYYY_HH-MM-SS.ZIP Figure 133 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 175 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
8.2.3.17 Device Test DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 176 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 177
*Scanning blocked during Error Viewer installation as of software > ARC_1404. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 177 of 218...
HealthCare Library and the printout provided with the spare part are different. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Hand it out to the customer after completion of the preventive maintenance. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Ask the customer for issues with the Digitizer since the last maintenance. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Keep the image for comparison after the maintenance. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 181 of 218...
No symptoms of bending or squeezing visible. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 182 of 218...
5151_ENC_016a.cdr Figure 136 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 183 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 184
5151_Maint_006.cdr Figure 139 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 184 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 185
It must be avoided that dropping grease contaminates the Digitizer. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 185 of 218...
5151_Maint_010.cdr Figure 144 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 186 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
5151_Maint_011.cdr Figure 146 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 187 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
5151_ENC_009.cdr Figure 148 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 188 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
5151_ENC_019.cdr Figure 150 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 189 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 190
5151_ENC_028c.cdr Figure 153 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 190 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Always drive back the cleaning brush to home position. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 191 of 218...
It must be avoided that dropping grease contaminates the image plates or the Cassette Unit. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 192 of 218...
Page 193
5151_Maint_015.cdr Figure 160 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 193 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Remount all parts. Refer to IMPORTANT note below. Connect power and network cable. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 194 of 218...
In case of image artifacts: Troubleshoot as described in section 7. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 195 of 218...
Page 2 of 2 Figure 164 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 196 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
In some cases wrong or incomplete error messages are displayed. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 197 of 218...
Photomultiplier flash memory is corrupted. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 198 of 218...
It remains on "feeding IP". DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 199 of 218...
10852 (Adjust Galvo failed) which may appear at a Digitizer fully warmed up and operated at higher ambient air temperature. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 200 of 218...
“feeding IP”, despite endurance run worked fine. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 201 of 218...
DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 202 of 218...
In software ARC_1304 the timing problem has been corrected. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 203 of 218...
110, 200 and 210 that were introduced in 04-2013. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 204 of 218...
Error Viewer shows now correct time stamps in its error history, i.e. the time when the error occurred. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 205 of 218...
Page 206
Counters for IP cycles and operating hours in the optic module and PMT with Light Collector are now working correctly. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 206 of 218...
* On the Agfa HealthCare Library only the latest software release can be downloaded. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Service function "Reporting > Error Statistics" does not crash anymore. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 208 of 218...
Page 209
Before only the limit pattern in native NX format was included. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
* On the Agfa HealthCare Library only the latest software release can be downloaded. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
The Digitizer Remote Display shows messages in Norwegian language, too. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 211 of 218...
2.0.8800 / 3.0.8800 Agfa Portal via Internet DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 212 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Stepper Motor Drawer Page 1 of 3 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 213 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 214
Wiring Diagram Page 2 of 3 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 214 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
Page 215
Wiring Diagram Page 3 of 3 DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 215 of 218 CR 10-X / CR Reader / CR 12-X / CR Advanced Reader / CR 15-X / CR Multiformat Reader...
On some PMI Boards the switches S1 and S2 are not available. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
** On only if there is ethernet traffic DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2 Page 217 of 218...
On some Power Boards / Power II Boars the switches S1 and S3 are not available. DOCUMENT CONTROL NOTE: The controlled version of this document is available from the Agfa HealthCare Library. Any printed copy of this document is uncontrolled. Edition 1, Revision 2...
Need help?
Do you have a question about the HEALTHCARE CR 10-X and is the answer not in the manual?
Questions and answers