Dodge Intrepid Service Manual page 1024

LH
Description
INSTALLATION, ANTENNA BODY &
CABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8A-5
INSTALLATION, A-PILLAR TRIM
INSTALLATION, ASSIST HANDLE
INSTALLATION, BACKLITE . . . . . . . . . . . . . . 23-97
INSTALLATION, BATTERY CABLES
INSTALLATION, BATTERY HEATER
BLANKET . . . . . . . . . . . . . . . . . . . . . . . . . . . 8F-16
INSTALLATION, BATTERY HOLDDOWN
INSTALLATION, BLEND DOOR ACTUATOR
INSTALLATION, BLOWER MOTOR . . . . . . . . 24-24
INSTALLATION, BLOWER MOTOR
RESISTOR BLOCK . . . . . . . . . . . . . . . . . . . . 24-16
INSTALLATION, BODY CONTROL
MODULE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8E-3
INSTALLATION, BODY SIDE MOLDINGS
INSTALLATION, BODY VENT . . . . . . . . . . . . 23-60
INSTALLATION, B-PILLAR LOWER TRIM
INSTALLATION, B-PILLAR UPPER TRIM
INSTALLATION, BRAKE LAMP SWITCH . . . . . 8L-5
INSTALLATION, BRAKE ROTOR (FRONT)
INSTALLATION, BRAKE ROTOR (REAR)
INSTALLATION, CAMSHAFT OIL SEAL(S)
INSTALLATION, CAMSHAFT SPROCKETS
INSTALLATION, CAMSHAFT(S) . . . . . . 9-114,9-29
INSTALLATION, CARPETS . . . . . . . . . . . . . . 23-63
INSTALLATION, CD CHANGER . . . . . . . . . . . . 8A-5
INSTALLATION, CENTER CONSOLE
ARMREST LID ASSEMBLY . . . . . . . . . . . . . 23-63
INSTALLATION, CENTER CONSOLE
BEZEL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-64
INSTALLATION, CENTER CONSOLE
CUPHOLDER ASSEMBLY . . . . . . . . . . . . . . . 23-66
INSTALLATION, CENTER CONSOLE LID
LATCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-66
INSTALLATION, CENTER CONSOLE REAR
BEZEL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-66
INSTALLATION, CENTER HIGH MOUNTED
STOP LAMP . . . . . . . . . . . . . . . . . . . . . . . . . . 8L-6
INSTALLATION, CENTER HIGH MOUNTED
STOP LAMP UNIT . . . . . . . . . . . . . . . . . . . . . 8L-7
INSTALLATION, CHECK STRAP . . . . . 23-19,23-27
INSTALLATION, CHILD TETHER CUP
INSTALLATION, CHILD TETHER CUP
COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8O-5
INSTALLATION, CIGAR LIGHTER/POWER
OUTLET . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-97-3
INSTALLATION, CLOCK . . . . . . . . . . . . . . . . . 8C-1
INSTALLATION, CLOCK SPRING
INSTALLATION, CLUSTER BEZEL
INSTALLATION, CLUSTER LAMPS . . . . . . . . 8L-37
INSTALLATION, COMBINATION FLASHER
INSTALLATION, COMPASS/MINI-TRIP
COMPUTER . . . . . . . . . . . . . . . . . . . . . . . . . 8M-8
INSTALLATION, CONCORD . . . . . . . . . . . . . 23-67
INSTALLATION, CONCORDE . . . . . . . . . . . . 23-36
INSTALLATION, CONNECTOR . . . . . . . . 8W-01-11
INSTALLATION, CONTROLLER ANTILOCK
BRAKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8E-6
INSTALLATION, COOLANT OUTLET
CONNECTOR - 2.7L . . . . . . . . . . . . . . . . . . . . 7-19
INSTALLATION, COVER . . . . . . . . . . . . . . . . 23-13
INSTALLATION, COWL GRILLE AND
SCREEN . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-35
INSTALLATION, CRANKSHAFT . . . . . . . 9-132,9-43
INSTALLATION, CRANKSHAFT MAIN
BEARINGS . . . . . . . . . . . . . . . . . . . . . . . . . . 9-135
INSTALLATION, CRANKSHAFT OIL SEAL -
FRONT . . . . . . . . . . . . . . . . . . . . . . . . . 9-136,9-47
INSTALLATION, CRANKSHAFT OIL SEAL -
REAR . . . . . . . . . . . . . . . . . . . . . . . . . . 9-137,9-48
INSTALLATION, CRANKSHAFT POSITION
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-26
INSTALLATION, CRANKSHAFT REAR OIL
SEAL RETAINER . . . . . . . . . . . . . . . . . 9-138,9-49
INSTALLATION, CRANKSHAFT SPROCKET
INSTALLATION, CROSS CAR BEAM . . . . . . . 23-62
INSTALLATION, CV BOOT-INNER . . . . . . . . . . 3-11
INSTALLATION, CV BOOT-OUTER
INSTALLATION, CYLINDER HEAD
INSTALLATION, CYLINDER HEAD
COVER(S) . . . . . . . . . . . . . . . . . . . . . . 9-115,9-31
INSTALLATION, CYLINDER HEAD OFF . . . . . 9-126
INSTALLATION, CYLINDER HEAD ON
INSTALLATION, DASH SILENCER
INSTALLATION, DECK LID RELEASE
SOLENOID . . . . . . . . . . . . . . . . . . . . . . . . . . . 8N-4
Group-Page Description
INSTALLATION, DECK LID RELEASE
SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8N-4
. . . . . . . . . 23-60 INSTALLATION, DECKLID
. . . . . . . . 23-60 INSTALLATION, DECKLID SECURITY
SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8Q-3
. . . . . . . 8F-15 INSTALLATION, DECKLID/TRUNK LAMP
INSTALLATION, DIAGNOSIS AND
TESTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8E-7
. . . . 8F-13 INSTALLATION, DIAGNOSIS AND
. 24-19 TESTING . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-123
INSTALLATION, DIAGNOSIS AND
TESTING . . . . . . . . . . . . . . . . . . . . . . . . . . . 8L-20
INSTALLATION, DIAGNOSIS AND
TESTING . . . . . . . . . . . . . . . . . . . . . . . . . . . 8M-15
INSTALLATION, DIAGNOSIS AND
. . . 23-34 TESTING . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-47
INSTALLATION, DIODE
. . 23-61 INSTALLATION, DOOR . . . . . . . . . . . . 23-19,23-28
. . . 23-61 INSTALLATION, DOOR CYLINDER LOCK
SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8N-5
. . . 5-53 INSTALLATION, DOOR GLASS . . . . . . 23-20,23-28
. . . . 5-53 INSTALLATION, DOOR HINGE DOUBLE
. . 9-113 ENDED STUD . . . . . . . . . . . . . . . . . . . . . . . . 23-21
. . 9-175 INSTALLATION, DOOR OPENING
WEATHERSTRIP . . . . . . . . . . . . . . . . . . . . 23-110
INSTALLATION, DOOR SILL TRIM . . . . . . . . 23-67
INSTALLATION, DOUBLE SIDED TAPE . . . . . 23-35
INSTALLATION, DOWNSTREAM 1/2, 2/2 . . . 14-35
INSTALLATION, DRIP RAIL
WEATHERSTRIP . . . . . . . . . . . . . . . . . . . . 23-111
INSTALLATION, DRIVE BELTS - 2.7L . . . . . . . . 7-15
INSTALLATION, DRIVE BELTS - 3.5L . . . . . . . 7-17
INSTALLATION, DRIVE MOTOR
INSTALLATION, DRIVER AIRBAG
INSTALLATION, DRIVER AIRBAG TRIM
COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8O-8
INSTALLATION, DRIVER HEATED SEAT
SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8G-11
INSTALLATION, DRIVER POWER SEAT
SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8N-17
INSTALLATION, ELECTRONIC VEHICLE
INFO CENTER . . . . . . . . . . . . . . . . . . . . . . . 8M-12
. . . . . . 8O-5 INSTALLATION, EMERGENCY RELEASE
CABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-16
INSTALLATION, ENGINE ASSEMBLY
INSTALLATION, ENGINE BLOCK HEATER
INSTALLATION, ENGINE COOLANT
TEMPERATURE SENSOR . . . . . . . . . . . . . . . . 7-21
. . . . . . . . . . 8O-6 INSTALLATION, ENGINE COOLANT
. . . . . . . . 23-44 THERMOSTAT - 2.7L . . . . . . . . . . . . . . . . . . . 7-23
INSTALLATION, ENGINE COOLANT
. . . 8L-8 THERMOSTAT - 3.5L . . . . . . . . . . . . . . . . . . . 7-23
INSTALLATION, ENGINE CRADLE
CROSSMEMBER . . . . . . . . . . . . . . . . . . . . . . 13-9
INSTALLATION, EVAPORATOR
TEMPERATURE SENSOR . . . . . . . . . . . . . . . 24-17
INSTALLATION, EVAP/PURGE SOLENOID
INSTALLATION, EXHAUST MANIFOLD -
LEFT . . . . . . . . . . . . . . . . . . . . . . . . . . 9-166,9-76
INSTALLATION, EXHAUST MANIFOLD -
RIGHT . . . . . . . . . . . . . . . . . . . . . . . . . 9-165,9-75
INSTALLATION, EXHAUST SYSTEM . . . . . . . . 11-4
INSTALLATION, EXTERIOR HANDLE
INSTALLATION, FLEX PLATE
INSTALLATION, FLOOR CONSOLE . . . . . . . . 23-68
INSTALLATION, FLUID COOLER
INSTALLATION, FOG LAMP
INSTALLATION, FOG LAMP UNIT
INSTALLATION, FRONT BUMPER
REINFORCEMENT . . . . . . . . . . . . . . . . . . . . . 13-1
INSTALLATION, FRONT CABLE
INSTALLATION, FRONT CALIPER
INSTALLATION, FRONT CALIPER
(EXPORT) . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-28
INSTALLATION, FRONT DISC BRAKE
. 9-177,
SHOES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-17
9-86
INSTALLATION, FRONT DISC BRAKE
SHOES (EXPORT) . . . . . . . . . . . . . . . . . . . . . 5-18
. . . . . . . . . 3-13
INSTALLATION, FRONT DOOR GLASS
. . . . 9-111,9-27
RUN WEATHERSTRIP . . . . . . . . . . . . . . . . 23-112
INSTALLATION, FRONT DOOR MOUNTED
WEATHERSTRIP . . . . . . . . . . . . . . . . . . . . 23-112
INSTALLATION, FRONT DOOR WINDOW
. . . . . 9-127 FRAME MOLDING . . . . . . . . . . . . . . . . . . . . 23-69
. . . . . . . . 23-45 INSTALLATION, FRONT FENDER
INSTALLATION, FRONT POSITION LAMP
- EXPORT . . . . . . . . . . . . . . . . . . . . . . . . . . 8L-14
Group-Page Description
INSTALLATION, FRONT SEAT BELT &
RETRACTOR . . . . . . . . . . . . . . . . . . . . . . . . 8O-11
. . . . . . . . . . . . . . 23-14 INSTALLATION, FRONT SEAT CUSHION
INSTALLATION, FRONT STRUT TOWER
TO TOWER BRACE . . . . . . . . . . . . . . . . . . . 23-36
. . . . 8L-8 INSTALLATION, FRONT TOW EYE
INSTALLATION, FRONT TOW HOOK
BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-10
INSTALLATION, FRONT WHEEL SPEED
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-67
INSTALLATION, FUEL LEVEL SENDING
UNIT / SENSOR . . . . . . . . . . . . . . . . . . . . . . . 14-6
INSTALLATION, FUEL PRESSURE
REGULATOR . . . . . . . . . . . . . . . . . . . . . . . . . 14-7
INSTALLATION, FUEL PUMP MODULE
INSTALLATION, FUEL TANK . . . . . . . . . . . . . 14-13
. . . . . . . . . . . . . 8W-01-14 INSTALLATION, FUEL TANK FILLER TUBE . . 14-14
INSTALLATION, FUEL TANK VENT TUBE
INSTALLATION, GEAR SHIFT CABLE -
COLUMN . . . . . . . . . . . . . . . . . . . . . . . . . . 21-102
INSTALLATION, GEAR SHIFT CABLE -
FLOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-104
INSTALLATION, GLASS PANEL
INSTALLATION, GLOVE BOX
INSTALLATION, GLOVE BOX LAMP . . . . . . . 8L-38
INSTALLATION, GLOVE BOX LAMP
SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8L-38
INSTALLATION, GLOVE BOX LATCH
INSTALLATION, GRILLE OPENING
REINFORCEMENT . . . . . . . . . . . . . . . . . . . . 23-37
INSTALLATION, HALFSHAFT
INSTALLATION, HCU
. . . . . . . . . 23-105 INSTALLATION, HEADLAMP
. . . . . . . . . 8O-7 INSTALLATION, HEADLAMP LEVELING
SWITCH - EXPORT . . . . . . . . . . . . . . . . . . . 8L-21
INSTALLATION, HEADLAMP SWITCH
INSTALLATION, HEADLAMP WASHER
HOSES - EXPORT . . . . . . . . . . . . . . . . . . . . 8R-12
INSTALLATION, HEADLAMP WASHER
NOZZLE - EXPORT . . . . . . . . . . . . . . . . . . . 8R-13
INSTALLATION, HEADLAMP WASHER
PUMP - EXPORT . . . . . . . . . . . . . . . . . . . . . 8R-14
INSTALLATION, HEADLINER
INSTALLATION, HEATED
. . 9-100,9-15 INSTALLATION, HEATED SEAT ELEMENT
. . . 7-20 INSTALLATION, HEATER CORE
INSTALLATION, HEATER SUPPLY TUBE -
2.7L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-24
INSTALLATION, HEATER SUPPLY TUBE -
3.5L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-25
INSTALLATION, HINGE
INSTALLATION, HOOD . . . . . . . . . . . . . . . . . 23-41
INSTALLATION, HORN
INSTALLATION, HORN RELAY . . . . . . . . . . . . 8H-4
INSTALLATION, HOUSING ASSEMBLY . . . . 23-104
INSTALLATION, HOUSING DRAIN HOSE
. . 25-12 INSTALLATION, HUB AND BEARING
(FRONT) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-6
INSTALLATION, HUB AND BEARING
(REAR) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-34
INSTALLATION, HVAC HOUSING
INSTALLATION, HYDRAULIC LASH
. . . . . . 23-20 ADJUSTERS . . . . . . . . . . . . . . . . . . . . . . . . . . 9-38
. . . . . . . . 9-139,9-49 INSTALLATION, ICU . . . . . . . . . . . . . . . . . . . . 5-79
INSTALLATION, IGNITION COIL
. . . . . . . . . 19-61 INSTALLATION, IGNITION COIL
CAPACITOR . . . . . . . . . . . . . . . . . . . . . . . . . . 8I-6
. . . . . . . . . . . . . 8L-10
INSTALLATION, IGNITION SWITCH
. . . . . . . . 8L-11
INSTALLATION, IN VEHICLE
INSTALLATION, INLET FILTER
INSTALLATION, INNER TIE ROD
. . . . . . . . . . . 5-55
INSTALLATION, INNER TIE ROD
. . . . . . . . . 5-28
BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . 19-50
INSTALLATION, INSPECTION . . . . . . . . . . . . 9-118
INSTALLATION, INSTALLATION
INSTALLATION, INSTALLATION
INSTALLATION, INSTRUMENT CLUSTER . . . . 8J-2
INSTALLATION, INSTRUMENT CLUSTER
MASK/LENS . . . . . . . . . . . . . . . . . . . . . . . . . . 8J-4
INSTALLATION, INSTRUMENT PANEL
ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . 23-48
INSTALLATION, INSTRUMENT PANEL
CENTER BEZEL . . . . . . . . . . . . . . . . . . . . . . 23-55
INSTALLATION, INSTRUMENT PANEL
END CAP . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-55
. . . . . . . . . 23-37
INSTALLATION, INSTRUMENT PANEL
SILENCER . . . . . . . . . . . . . . . . . . . . . . . . . . 23-56
INDEX
Group-Page
. . . 23-88
. . . . . . . . 13-10
. . . . . 14-9
. . . 14-14
. . . . . . . . . 23-105
. . . . . . . . . . . . 23-46
. . . . . . 23-46
. . . . . . . . . . . . . . 3-6
. . . . . . . . . . . . . . . . . . . 5-75
. . . . . . . . . . . . 8L-18
. . . . . 8L-21
. . . . . . . . . . . . 23-70
. . . . . . . . . . . . . . . 23-89
. . 8G-14
. . . . . . . . . . 24-41
. . . . . . 23-14,23-29,23-40
. . . . . . . . . . . . . . . . . 8H-3
. . 23-107
. . . . . . . . . 24-26
. . . . . . . . . . . 8I-5
. . . . . . . 19-23
. . . . . . . . . . . . . 9-35
. . . . . . . . . . . 14-14
. . . . . . . . . 19-44
. . . . 23-21,23-67,
23-72,23-80,23-82,23-83,23-86,23-94
. . . . . . . . . . . 13-2
17