Chery T21 2014 Service Manual page 160

05 - MAINTENANCE
10.Check the clutch pedal
11. Check the accelerator pedal.
a. Check that accelerator pedal operates smoothly. Check that pedal does not have uneven resistance or
stick in certain position.
Engine Compartment Inspection
1. Check the engine oil level
2. Check the accessory drive belt
3. Check the engine for oil leakage.
a. Turn off all the electrical equipment and ignition witch, and remove the key.
b. Support and raise the vehicle.
c. Check the crankshaft pulley for oil stains. If there are oil stains, check crankshaft front oil seal for
05
leakage. If there are leaks, replace the crankshaft front oil seal.
d. Check oil pan and drain plug for oil stains. Repair or replace related parts if necessary.
e. Check transmission filler plug, drain plug and case for oil stains. Repair or replace related parts if
necessary.
f. If crankshaft front oil seal leaks after repair, it may be caused by the following 3 reasons:
 Crankshaft thrust washer wear
 Crankcase ventilation system blockage
 Excessive engine oil
4. Check the battery.
a. Check the battery and battery voltage
b. Check the charging voltage of charging system
5. Check the cooling system hoses.
a. Check that there are no cracks, bent, corrosion or loose connections on the cooling system hoses.
Brake System Inspection
1. Check the brake fluid level.
CAUTION
 Generally, brake fluid level will change slightly because of wear of brake pad, but it must be kept between
"MIN" and "MAX" lines.
a. Park the vehicle on a level ground.
b. Make sure there is no air in the brake system and the depressing feel of brake pedal is well. Perform
brake bleeding procedures if necessary
c. Check if brake fluid level is between "MAX" and "MIN"
lines.
d. If brake fluid level drops to the "MIN" line or below,
add brake fluid and check brake system for leakage.
10
05–
(See page 19-9).
(See page 13-9).
(See page 07-24).
(See page
(See page
16-7).
(See page 16-6).
26-12).
Chery Automobile Co., Ltd.
RT21260050