Page 1 CHERY Company. Sevice Munual for CHERY QQ6 You are sincerely congratulated to be an owner of CHERY QQ6! Thank you for your belief for Chery Automobile Co., Ltd and your choice for Chery products! You will receive the high quality services from Chery Authorized Sales and Service Station whose employees have been trained well and specially.
Page 2 This manual covers the latest information vehicle during the operation, it must be our corporation are lost due to the until it is printed. Chery Automobile Co., overhauled and maintained by the Chery violation of the operational provisions. Ltd. is fully responsible for the revision authorized sales and service station, and CHERY Autombile Co., Ltd (hereinafter...
Page 3: Chapter 1 Brief Introduction
Content 未定义书签。 Chapter 1 Brief Introduction 错误！未定义书 Light Control ..........错误！未定义书签。签。 Headlamp Switch ......... 错误！未定义书签。 Safety and Environmental Protection ... 错误！未定义书签。 Headlamp Dimmer ........错误！未定义书签。 Check of A New Vehicle ......错误！未定义书签。 Headlamp Flasher ......... 错误！未定义书签。 Run-in of A New Vehicle ......错误！未定义书签。 Front / Rear Fog Lamp Switch .....
Page 4: Table Of Contents
Content External Power Interface ......错误！未定义书签。 Three-way Catalytic Converter ....错误！未定义书签。 Door Lock and Theft Prevention ....错误！未定义书签。 Parking ............错误！未定义书签。 Vehicle Keys ..........错误！未定义书签。 Fuel Consumption ........错误！未定义书签。 Centrol Door Lock System ......错误！未定义书签。 Radiator Fan ..........错误！未定义书签。 Rear Door Child Lock ........错误！未定义书签。 Emergency Assistance ........
Page 5 Fuel .............. 错误！未定义书签。 Emergency Maintenace Guide...... 错误！未定义书签。 Ening Oil ............错误！未定义书签。 Introductioni ..........错误！未定义书签。 Automobile oil/fluid ........错误！未定义书签。 Full use of your CHERY Authorized Service Station错误！未定义 Vehicle ............错误！未定义书签。书签。 Wheel and Tire ..........错误！未定义书签。 First aid ............错误！未定义书签。 Engine Data ..........错误！未定义书签。...
Page 6 Brief Introduction Chapter Brief Introduction...
Page 7: Brief Introduction
Thank you for your purchasing a resale value of your vehicle. And many Warning Symbols In  Chery vehicle. To help you use your skillful auto repair technicians from Chery This Manual car properly and ensure your benefit, Authorized Service Stations nationwide...
Page 8 Prior to hand over the vehicle to you, the errors, the frictional resistance between the you must read the relating chapters in this dealer of Chery Automobile has already moving parts of a new vehicle will be manual. carried out inspection in accordance with much larger than normal condition at the the provision specified by Chery Company.
Page 9 Brief Introduction  In general, it shall not exceed 100km the red indication area, it must switch into necessary. Under such circumstance, when / h; the adjacent high gear. driving during the first 100 km, it ought to be relatively slow, and the driver should be ...
Page 10 One-to-One Service  To provide better vehicle services as well as application, a Chery vehicle dealer will appoint one service consultant for you...
Page 11 Brief Introduction Vehicle Delivery and Inspection Record: This vehicle's delivery inspection has been Registration finished in accordance with the provision number： specified by Chery Company Limited, and the quality conforms to the technical specification Owner Service Station _________________ ________________ of Chery Company. And the certification is Name（unit）...
Page 12 Brief Introduction Seal of dealer Date of Vehicle Delivery: Vehicle Model Body VIN number Engine No. Transmission No...
Page 13 Brief Introduction Vehicle Sales and Devlivery Card of CHERY Whether inspected and Category Item clarified or not □ □ Engine □ □ Engine oil, brake fluid, steering fluid, coolant, electrolyte, windshield washer fluid □ □ Identifications such as VIN number, engine number, nameplate, etc.
Page 14 Brief Introduction □ No No □ 93# gasoline for fuel...
Page 15 Brief Introduction Proper use in running-in period □ □ □ □ Operation of complete set of vehicle lights □ □ Meanings of warning light. □ □ Proper maintenance time and mileage □ □ Items of vehicle maintenance in winter/summer □ □...
Page 16 Authorized Service Station has been acknowledged. □ "Maintenance Manual" and "Instruction Manual" have been delivered, and reminded the owner to read carefully □ Usage and function of Chery Company's customer service hot Business card of service line have been acknowledged consultant II.
Page 17 Brief Introduction...
Page 18 Authorized Service Station has been acknowledged. □ "Maintenance Manual" and "Instruction Manual" have been delivered, and reminded the owner to read carefully □ Usage and function of Chery Company's customer service hot Business card of service line have been acknowledged consultant II.
Page 19 Operation & Adjustment of Interior Devices Description of Common Symbols on Vehicle Symbol Definition Symbol Definition Symbol Definition Antilock braking CHECK ENGINE Position light system Glass Drive Switch Engine oil pressure Safety warning Prohibitted warning light Coolant temperature Throttle fault Rear Fog Lamp overhigh warning...
Page 20 Operation & Adjustment of Interior Devices Symbol Definition Symbol Definition Symbol Definition Battery Seat belt ready Windshield washing Hazard warning High beam Horn flasher Vehicle maintenance Low beam Battery positive indicator fault Windshield Headlamp switch indicator light defrosting/defogging Parking brake Fuel level low Inner circulating air indicator light...
Page 21 Operation & Adjustment of Interior Devices Symbol Definition Symbol Definition Symbol Definition Indicator for interior Unlock indicator lamp switch Warning light door and trunk lid Audible alarm open Right turn signal Left turn signal lamp indicator lamp indicator...
Page 22 Operation & Adjustment of Interior Devices Chapter 2 Operation & Adjustment of Interior Devices...
Page 23 To lock the steering wheel, after avoid using up the power of battery. Steering Wheel Lock & removing the lock, the steering wheel – Switch on the ignition circuit to Ignition Switch shall be turned slightly until you hear enable all electrical circuits to work. the engage sound of steering wheel Both warning lamp and indicator light.
Page 24 In the cold seasons, you shall avoid damaging the engine and the Press down the button on the check whether the wiper engine flywheel. steering wheel to operate the horn. You blade frozen windscreen prior to the use of wiper. If also can operate the horn even when If failing to start, the ignition key must the blade is frozen on the windscreen,...
Page 25: Interior Rearview Mirror
INT (Intermittent Wipe) HI (High-Speed Wipe) from the nozzles in front of the windshield and at the same time the wipers operate. The operation of water-jet must not be more than 10 seconds, and the operation cannot be done if cleaning liquid is not available in the reservoir of Shift the control lever upward to INT cleaning...
Page 26 or leftwards to adjust the angle of the...
Page 27: Sun Visor
Driving Control Switches rear-view mirror if you want to reduce Left rear-view mirror Doors the glare when driving at night. When adjusting position the doctor bar is turned leftwards, the Central rear-view mirror turns downwards a Position certain angle; when the bar is turned Left rear-view mirror adjusting position rightwards, the mirror turns upwards a...
Page 28 Driving Rear Door When the control switch is turned left The rearview mirror can be resumed to or right to the proper position, push the its original position by unfolding it switch foreword, backward, leftward outward to the proper position. and rightward respectively to adjust the The image in the convex position of mirror surface upward,...
Page 29 Driving The window lift control switch has delay function, that is, it can still NOTICE: operate within 60 seconds after pulling Take car to close the windows! It is to There is a safety switch button on the out the key. be noted that you shall observe the door trim panel at the side door.
Page 30: Headlamp Switch
Driving Lighting switch is off, the cigar lighter can also be used. Control Backlight Regulating Headlamp Switch Switch Cigar OFF – Turn off the exterior lamps. Lighter Front Ashtray Side Light: While operating the following lighting Turn the headlamp switch on the equipment, please abide by relevant instrumental panel to the 1 position (i.e.
Page 31 Driving operating backlight regualting handle, and pass through the force continuously. switch. point and then convert into the high beam. The high beam indicator lamp Low beam: in the dashboard is also light on Front/Rear Fog Lamp Turn the headlamp switch on the together with the headlamp high beam.
Page 32: Trunk Lamp
Driving Turning Signal Lamp Interior front ceiling lamp Remind that the headlamp switch shall be turned on (at 1 or 2 position) first in order to turn on the fog lamp. Turn on the front fog lamp, and then turn on the rear fog lamp.
Page 33: Backup Lamp
Driving Backup Lamp on (but it is not under the control of the give an alarm to the vehicles which ignition switch). After parking, please follow your vehicle and tell them that After turning on the ignition switch and notice to cover the trunk properly. your vehicle has trouble or hazard.
Page 34 Driving Chapter 3 Driving...
Page 35 To start up the electronic injection Confirm that the front headlamp to the Chery Authorized Service engine, do not step on the gas pedal and other electrical accessories Station to make your vehicle repaired.
Page 36: Start The Engine
If the lamp foot brake, release the handbrake doesn’t light, it is required to get -12C and it is difficult to start and shift to a drive gear to the engine within 5 seconds for to the Chery Authorized Service...
Page 37 The ambient temperature range Chery Authorized Service ventilation system of the car. applicable to normally start an Station to overhaul the car and do not continue to drive. The exhaust fume is  engine is -25℃ - 40℃ (when the Lifts the car for overhaul.
Page 38 Driving Self-adapting function Shut down the engine Note: of the engine’s control The engine temperature will remain high after the ignition switch is turned system off and the engine stops, so, leave the electronic cooling fan of the radiator continue to run for about 10 minutes. If the battery cable has been ever Even if the cooling fan stops running, it removed, some abnormal phenomena...
Page 39: Brake Fluid
Then, and driving method. For a vehicle dual-circuit brake system. In case one send the car to a Chery Authorized mainly used in urban traffic, the of the two circuits fails, the other Service Station for overhaul.
Page 40: Brake Booster
Driving If the front spoiler is added on maintenance mileage. the car, ensure that the airflow to the front brake is unblocked; otherwise, the When running downhill, shift to a Brake booster: brake system may overheat due to poor lower gear timely to make full use of heat emission, thus reducing braking effect.
Page 41 Please drive failure occurs in ABS system; then, Keep applying the brake pedal with full with care and slow down when stop the car and contact a Chery turning. force during an emergence may initiate Authorized Service Station.
Page 42 Driving Hand brake To release the hand brake, pull up the important principle hand lever slightly, press down the brake release button at the end of the handle and simply push it down. The hand brake applies action on the rear wheel.
Page 43 Driving the engine torque. should keep pressing the gearshift steering system: lever, thus greatly reducing   Apply a slow speed gear when When the engine is running, do sliding and rubbing time of the running downhill and turning; not turn the steering wheel to its synchronizer’s lock ring and sliding with...
Page 44  If any steering component is loose may damage the transmission. scope maintenance guarantee. or worn Please contact the nearest Chery After paddling, be sure to drive slowly Authorized Service Station  If wheel alignment is correct immediately if you have added the and slightly apply the brake pedal for leady fuel by accident.
Page 45 During driving, drive the Avoid any case that may cause car at a lower speed to the nearest Chery Authorized unburned or partly unburned fuel to It is absolutely unallowable to Service Station in case of poor...
Page 46: Fuel Consumption
Driving Good driving habit personnel injury or property damage. Foreseeing the dangerous condition and Chassis protection keeping a safe running distance with You car is equipped with heat shield. the vehicle before can reduce not only The above chart indicates Do not apply any painting dressing on how the fuel consumption is affected the fuel consumption but also wear and...
Page 47: Radiator Fan
(about 10 for the car, which should be minutes) because the engine is still driving and environmental under a thermal state and it will stop implemented Chery protection: running until cooled to a certain Authorized Service Station temperature.
Page 48 Driving shifting to a lower gear can not increase the cooling effect of the fan. Therefore, need not to shift to a lower gear when the engine runs smoothly and its speed does not fall obviously when climbing.
Page 49 Instrument Panel Chapter 4 Instrument Panel...
Page 50: Instrument Panel
Instrument Panel Instrument Steering Turn Signal & Wheel Position Lamps Combination Wiper Switch A/C Vent Switch Instrument A/C Vent Panel Wind Direction Exterior Engine Hood Nightlight Horn Switch A/C System Audio System Glove Box Adjusting Knob Rear-view Pull-up Switch Adjusting Mirror Knob Switch...
Page 51 Instrument Panel 7. Airbag Warning Light 13. Right Turn Signal L 1. Left Turn Signal Lamp Indicator 8. Brake System Warning Light Indicator 2. Door Open Warning Light 9. Engine Oil Low Warning Light 14. Maintenance Indicator 3. Battery Charging Indicator 10.
Page 52: Warning Devices
ABS system will perform please drive your vehicle to the CHERY self-checking at the same time and Authorized Service Station to make the determine whether the system is in good related system repaired.
Page 53: Brake System Warning Light
Instrument Panel Parking brake warning light Engine fault warning lamp please get to the CHERY Authorized Service Station to make this system inspected. If the brake system warning light lights This warning light works only after the during driving, it indicates...
Page 54: Airbag Warning Light
In the case, drive indicator light will flash at the same time. soon as possible to make your car the vehicle to the CHERY Authorized examined and repaired. Service Station to make this system If the flashing rate of the turn signal examined.
Page 55 In case that OFF is selected, the indicator flashes to give an alarm to the driver. the nearest CHERY Authorized Service light of PAB (Passenger Airbag) on the In case that the engine oil pressure is...
Page 56: Warning Light
Instrument Panel vehicle must overhauled This warning light is located at the center throttle, please get to the nearest CHERY professionals. of the clock display on the center of Authorized Service Station as soon as instrument panel. When the ignition...
Page 57 Instrument Panel Maintenance indicator light Engine coolant thermometer zone for a long time, please drive your vehicle to the CHERY Authorized Service Station to make your car examined and repaired. C to H – Normal temperature zone When the mileage reading on the...
Page 58: Fuel Gauge
The needle of fuel gauge leaves the ―F damaged or even broken due to impact. (Full)‖ position only after the vehicle is In this case, please get to the CHERY Authorized Service Station in time to fully refueled and then travels a stretch of...
Page 59 The speedometer is subject to the fuel mileage/instantaneous fuel influence of size of the vehicle’s tires. consumption/average fuel Please utilize the CHERY’s authorized consumption/average consumption/clock display (which can be tire with the same size of original tire, fuel consumption/clock switched).
Page 60 Instrument Panel The method to adjust the MIN digit of the clock, with one minute The red area in the upper right side of the increament every one press. And pressing dial represents the highest allowable clock display this button for a long time will speed range that the engine can get in a automatically increase the value of MIN short period of time under the operating...
Page 61 Ventilation and A/C System Chapter 5 Ventilation and Air Conditioning (A/C) System...
Page 62: Air Conditioner System
Ventilation and A/C System Air Conditioner System VENTILATION The outside air enters the vehicle via intake front windscreen. Please keep the air intake located under the window glass free of snow cover, tree leaves, and other foreign materials to ensure that the heating and ventilating parts can normally and effectively operate.
Page 63 Ventilation and A/C System Windscreen Vent Side Defroster Vent Side Defroster Vent Instrument Panel Vent Floor Vent...
Page 64: Central Vent
Ventilation and A/C System Side vent Front windscreen defroster vent Central vent The conditioned air flows into the The cold or hot air is guided to the side The conditioned air flows into the interior of vehicle via two side vents. windows via this vents (controlled in interior of vehicle via two central vents.
Page 65 Ventilation and A/C System Ventilation and warm air Control Panel The A/C system mixes the cold air The velocity of air flow depends on 1. Temperature control knob with adjust the blower. Turn on the blower 2.Air flow distribution knob temperature which is kept constant during driving, if necessary.
Page 66: Temperature Control Knob
Ventilation and A/C System speed of blower (4 positions in total). The vehicle. Temperature control knob velocity of wind is adjusted by the blower. It is applicable for the normal ventilation, To improve the comfortability, turn on the heating and cooling. The temperature control knob is used to blower during drviing.
Page 67 Ventilation and A/C System Air flow distribution knob The air flows out from the central and side vents. This knob is ued to select the direction of air flow. This knob has the following five positions: “Foot defrosting” position ( The air flows out from the lower “Head and foot”...
Page 68 Ventilation and A/C System defroster vents front window This switch is used to turn on/off the conditioner will make the engine hot. defroster vents. compressor of the A/C system. Observe the water temperature gauge, and turn off the air conditioner if the engine is Start the engine, turn the blower knob to overheat.
Page 69 Ventilation and A/C System Betweenn the blue (cold) and red (hot). Blower knob: Optional Head and foot It is normal cooling when the vehicle It is used to the transition period, such as travels for a long distance and travels at exterior temperature low, no sunshine.
Page 70 Ventilation and A/C System Blower knob: Optional the window frosts or becomes wet, turn off the inner circulation switch. The ―forced heating‖ is applied only to rapidly increase temperature, and then returns back to the ―normal heating‖ ASAP. Defrosting Forced heating A/C SWITCH: OFF or ON A/C SWITCH: OFF Inner/Outer circulation control lever:...
Page 71 Ventilation and A/C System Inner/Outer circulation control lever: exterior air and windscreen to make the internal surface of windscreen frosting Outer circulation ( and affect the eye reach. Air flow distribution knob: ( Temperature control knob: in the red area Operation prompt on cooling Blower knob: Appropriate position system...
Page 72 Ventilation and A/C System more, operate the engine at the idle speed and turn on the air conditioner even in winter, at least once every month. with duration several minutes so as to keep the appropriate lubrication and sealability of engine and extend the service life of the system.
Page 73 Door Lock & Theft Prevention Chapter 6 Door Lock & Theft Prevention...
Page 74: Door Lock
Door Lock & Theft Prevention of vehicle, DO NOT leave the key code Before leaving the vehicle, plate in the interior of your vehicle. please lock all doors and The code plate shall be placed in a luggage boot lid in case of Door Lock &...
Page 75: Door Lock And Theft Prevention
Door Lock & Theft Prevention Child lock closing the door. controller while you leave your vehicle. When leaving your vehicle, lock the Central door lock ( ) left front door from the exterior of the The central door lock is controlled by vehicle with the key only.
Page 76 Door Lock & Theft Prevention In the hot whether, the this door can’t be opened when you are doors only. interior temperature raises sitting in the interior, and the door quickly after the engine stop operating. If the human being or inner handle is also secured to the Open the trunk lid animals is in the high-temperature...
Page 77 Door Lock & Theft Prevention Open the engine hood pull bar, and pull upwards engine hood at the same time. Pull up the release handle to unlock the engine hood lock. Pull up the release lever at the left side Lift up the engine hood, and then of driver’s seat to open fuel tank refiller support it with the support bar.
Page 78: Engine Hood Open
Door Lock & Theft Prevention If the frequency of your engine hood must be lift upwards remote controller to determine whether the engine The remote controller covers approx. 6 disturbed, cannot unlock the locks, and then you can hood lock is fully engaged. m.
Page 79 Door Lock & Theft Prevention 28 s. safety of vehicle theft prevention. The anti-theft system can enter into the anti-theft state Replace battery The chip, built in each key, integrates only while all the doors, remote controller the key, electronic anti-theft equipment engine hood and trunk lid fully close.
Page 80 Door Lock & Theft Prevention vehicle key by accident, you shall go to the CHERY Authorized Service Station A.S.A.P. to make a new key matchable with your vehicle key. The Service Station has the special electronic equipment which can be used to make a new key for your vehicle and invalidate your lost key.
Page 81 Seat and Safety Protection Chapter 7 Seat and Safety Protection...
Page 82: Seat And Safety Protection
Seat and Safety Protection Seat and Safety Protection Front Seat Rear Seat...
Page 83: Correct Sitting Posture
Seat and Safety Protection Correct sitting posture when driving, and his/her legs also Seat and Safety shall bend slightly so that he/she The seats, head restraints, seat belts and can step on the pedal to its extreme. airbags all are helpful to protect the ...
Page 84 Seat and Safety Protection backrest. Adjust the backrest to the your desired angle, and then place down the handle seat to secure the seat backrest. If the seat is adjusted during Knob Handle driving, it may result that the vehicle is out of control. So, the seat can be adjusted only when There are an adjusting knob and an the vehicle stops.
Page 85: Front Head Restraint
Seat and Safety Protection seat forwards and backwards. After the vertebrae if your vehicle is impacted by height according to her/his body height seat is adjusted to its proper position, other vehicle during driving. so that the head restraints can effectively release the adjusting lever, and then However, the head restraint can be able protect you.
Page 86 Seat and Safety Protection the figure, and then fold the rear backrest when the head restraint is reassembled, in the direction of arrow as shown in the the head restraint of front/rear seat shall figure. be differentiated firstly (the head restraint of front seat is big while the head restraint of rear seat is small), and then Return the rear seat...
Page 87: Seat Belt Warning Light
Seat and Safety Protection The driver and passanger Seat belt sitting in the front seats shall wear the seat belts when driving. Avoid to put on too loose The seat belts/child safety seats must be chothes. To get the best protection applied at any moment.
Page 88: Center Of Rear Seat
Seat and Safety Protection Maintenance of seat belt ignition switch turns on. The light will keep lighting remind that passengers shall wear their seat belts. Seat belt check This light extinguishes after wearing the driver-side seat belt. Fasten the seat belt The length of this seat belt can’t be Pull out the belt smoothly and steadily.
Page 89 The belt stretched (e.g. after a traffic belt. accident) shall be replaced immediately Please DO NOT use the by the CHERY Authorized Service chemical cleaning agent, Airbag ( ) Station and the relevant parts shall be...
Page 90: Front Airbag
Seat and Safety Protection The seat and backrest shall be positioned correctly to work together with the airbag The severe frontal impact (on the front of to get the best protection effect. Use the axle center or within the range of left and The passenger in the front seat can be erect sitting posture and make the lower right 25 degrees departure from the...
Page 91: Child Safety Seat
For the sake of your safety, please get to the CHERY Authorized Service Station to check your vehicle It is recommended by the manufacturer...
Page 92 Seat and Safety Protection  For the child whose age is less than 12 seat on the rear seat. The little child whose age is below years or whose height is below 150 cm, a 4 years and whose weight is special child safety seat (such as infant between 10 to 18 kg shall sit in the seat, child safety seat or heightened...
Page 93 Seat and Safety Protection Any a safety seat is limited to be able to ensure that the diagonal a infant. belt crosses the shoulder properly. Based on the provisions of road traffic safety laws, it is absolutely The heightened seat position can prohibited that children sit on the front ensure that the adult seat belt is seat.
Page 95 Audio System Chapter 8 Audio System...
Page 96: Audio System
Audio System NOTICE: If this vehicle is equipped with the audio systems which are NOT indicated below, please carefully read the audio instrucation manual accompanied with the vehicle. CD Panel (...
Page 97 Audio System Panel Description USB sound module (switch sound module) button Preset button 3 (Radio) FM/AM(Radio FM/AM band switch) button REPEAT button CD(CD play selection) button Preset button 6 (Radio) /DISC select the previous disc (CD Cartridge) CD entrance Preset button 2 (Radio) LCD display Preset button 5 (Radio) Exit button...
Page 99: Emergency Assistance
Emergency Assistance Method of Operation Basic Operation NOTICE: Please refer to the front view in the Section ―Description‖ to read this chapter. WARNING: Please decrease the volume of sound prior to turn off the ignition key or the main power supply. This machine can memory the finial setting value of volume prior to shut down the machine.
Page 100 Emergency Assistance Press the POWER button to turn on/off the machine. Select the mode Press the FM/AM button to select the required band. Press the CD button to select the CD play mode. Press the USB button to select the USB sound module play mode (after connecting the Adjust the volume Turn the knob in the clockwise direction to increase the volume;...
Page 101 Emergency Assistance Adjust the bass Press the SEL button to select the ―BASS‖. Turn this button in the clockwise direction to increase the bass; and turn the button in the anticlockwise direction to decrease the bass. *Its value is set as ―0‖ prior to leaving factory. The range of adjustment: -7 to +7.
Page 102: Loudness Function
Emergency Assistance Adjust the balance Press the SEL button to select the ―BAL‖. Turn this button in the clockwise direction to increase the volume of right speaker; and turn the button in the anticlockwise direction to increase the volume of left speaker. *Its value is set as ―0‖...
Page 103 Emergency Assistance Method to Operate the Radio Tune into broadcasting Press the FM/AM button to select the Radio mode. Press the FM/AM button to select band, and when you press the FM/AM button, the button will convert according to the following sequence: FMFM1FM2AMFM….
Page 104: Manual Tuning
Emergency Assistance Station Search sensitivity (for FM band only)  The Local/Remote mode switch is available. The specific method of operation is as follows: Press the button SET for at least 2 seconds to enter the SETUP menu. Press the button to select the SRCH option that you want to change.
Page 105 Emergency Assistance  Press the button  to tune into the higher-frequency radio station. Automatic storing (AST) You can store 6 powerful FM radio stations in the FM AST band or store 6 radio stations in the MW (AM) AST band. When you use the automatic storing function, the radio stations that are originally stored in the FM AST or MW (AM) AST band will be covered.
Page 106 Emergency Assistance Method to operate the CD player CD play  Make the disk enter the CD entrance, and there is the word ―LOAD‖ in the display of the machine, and then the machine begins to play.  Screen display: -- Sound effect mode (if selected) -- CD play symbol -- Current track number, time elapses.
Page 107 Emergency Assistance = to previous track -- Start to play the track after the completion of selection. Fast Backward/Forward  Press the button or  to fast backward or fast forward the selected track. -- Press this button again to make the machine return to the normal play mode. Random play ...
Page 108 Emergency Assistance  After a disk ejects from the machine, please place it into the CD box to prevent from damaging or foreign particles.  Please avoid CD heating or exposing to long period of direct sunshine. Method to Operate the MP3(USB) Player Connect the moveable storage device which stores the mp3 muisc to the interface, and press the USB button to enter the MP3 play mode.
Page 109 Emergency Assistance Fast Backward/Forward  Press the button or  to fast backward or fast forward the selected track. Press this button again to make the machine return to the normal play mode. Random play  Press the RANDOM button to enter the random play mode. -- Press the button to exit the random play mode.
Page 110 Emergency Assistance Chapter 9 Emergency Assistance...
Page 111: Hazard Warning Flasher
Please get to the Chery to start the engine. In this case, the Authorized Service Station emergency assistance conducted by the The hazard warning flasher is applied...
Page 112 Emergency Assistance Please take care to properly use  Please take care to abide by the bulbs are replaced. However, it may compressor while local related laws and regulations cause great trouble when no tools are fueling. when you carry the spare canned available.
Page 113 Bulb of headlamp: Bulbs of license plate, aligned after the headlamp bulb is replaced every time. parking, side CHERY Authorized Service Station offers you the best service. 12V 55W directional high Bulbs of turn signal, Headlamp group (including...
Page 114 (under the sound isolation To replace the front fog lamp bulb, gasket) used to fasten the tail please get to the CHERY Authorized lamp from the internal side of Service Station to replace it. luggage boot. Then unscrew three...
Page 115: License Plate Lamp Bulb
If necessary, please Unscrew the protective cover of Installation position: over the license get to the CHERY Authorized the bulb in the anticlockwise plate. Service Station make direction according repaired.
Page 116: Interior Front Ceiling Lamp Bulb
Please pay attention for emergency use. housing again. to the laws and regulations applicable CHERY Authorized Service during adjustment. Luggage boot light bulb Station has various specifications of Installation position: at the middle of spare fuses.
Page 117 CHERY Authorized Service Station. Cartridge fuse Replace the fuse Color Code of Fuse Color Ampere...
Page 118: Engine Compartment Fuse Box
Emergency Assistance Your vehicle is accompanied with a fuse extractor. You can find it in the fuse box of the engine compartment. Engine Compartment Fuse Box:...
Page 119 Emergency Assistance This fuse box is located at the right side of the engine compartment, and behind the battery. During checking or replacing the fuse, loosen the latch of engine hood and then pull up the hood cover to remove the cover of the fuse box (―B+‖ is the primary power of the fuse box).
Page 120: Spare Wheel
Emergency Assistance Spare wheel screws attached to the body are inserted Replace the wheel into any installation hole of the tire, The spare wheel is stored in the Please take care to abide by luggage boot. Park your vehicle in the proper position, following precautions before the vehicle is jacked...
Page 121: Jack Lift Point
Emergency Assistance The jack is placed in front of spare The maximum working load of wheel stored in luggage boot. a jack is 1,000 kg. Jack lift point Remove the wheel The jack is available to bear the Make sure that the vehicle parks specified position of the bottom of car on a reliable level ground and the as shown in the figure only.
Page 122 Collect the jack and disable figure below. dismount the wheel. wheel in the reserve order and fix them. Install the wheel Please CHERY Push the wheel to the wheel Authorized Service Station cotter, and screw up the wheel A.S.A.P. to make the wheel nut...
Page 123: Battery
Emergency Assistance Battery doctor immediately. If the acid liquor splashes to your skin or Safety recommendations clothes, you can use the alkaline Take care to apply the water (soap) to neutralize the acid following preventive and then clean it with fresh water. measures when carrying the battery.
Page 124 Chery Authorized abnormal performances during Service Station. the initial stage of driving. This is Disassemble and install that the engine control system is ...
Page 125: Engine's Battery-Assisted Start Method
Emergency Assistance Engine’s Connect the down-lead started. The jumper wire shall be battery-assisted start fixed so as to avoid that it contact method the motion parts in the engine Park the vehicles properly to compartment. In the case that the vehicle battery has avoid the batteries contacting DO NOT connect the lead B no power, the engine of the vehicle can...
Page 126: Breakdown Trailer
Emergency Assistance Please turn on the fan and The ignition switch of the The engines of both vehicles electrical heating type rear vehicle trailed shall be in the shall run for three minutes before ―ON‖ position to make all the windscreen of the vehicle equipped with low power battery in steering wheel, turn signal lamp and...
Page 127 Maintenance and Care Chapter 10 Maintenance and Care...
Page 128: Maintenance And Care
CHERY Authorized Service maintenance methods will be addressed maintenance, examination, and repair, Stations only. in detail. Please carefully read it. which shall be done by the CHERY Authorized Service Station. CHERY Authorized Service Station is the unique maintenance...
Page 129: General Maintenance
Maintenance and Care Maintenance Sheet below, for your domestic waste or drain it into the strict, professional training conducted reference only.) public drainage system. by the CHERY Automobile Co., Ltd. Everyone shall concern about offer high-quality The brake fluid, coolant and power environment.
Page 130 Maintenance and Care Scheduled Maintenance NOTICE: ventilation system have no any Sheet damage and bend symptom. The A/C system shall operate for at least 30 minutes every month. Daily check: Monthly check: Keep the engine oil, lubricant grease and oil/fluid out of the Check the working condition of all reach of a child.
Page 131 Maintenance and Care Maintenance Items of the Engine Compartment Power Steering Fluid Reservoir Brake Fluid Reservoir Access Hole for Battery Maintenance Windscreen Cleaning Fluid Engine oil dipstick Reservoir Coolant Filler Opening Auxiliary Coolant Radiator...
Page 132: Engine Oil Filler Cap
Please DO NOT open the conforming to CHERY’s specifications cap when the engine is operating. Regularly check the engine oil, e.g., only until the oil level reaches the area when refueling or before a long-distance between the MIN and MAX marks.
Page 133: Engine Coolant Reservoir
―Capacity and Specification Parameters‖ operate at the idle speed for about 1 in this manual. Get to the CHERY Brake fluid minute, and then shut down the engine. Authorized Service Station to check the Please DO NOT let the brake leakage of this system A.S.A.P.
Page 134 So, please use the coolant conforming to Regularly observe the capacity of coolant which conforms the CHERY’s specifications. DO NOT coolant in the auxiliary radiator. specifications of this vehicle. substitute the coolant with the main Refill the coolant in time if below water.
Page 135: Windscreen Washer System
CHERY’s new battery must be the same as that of Please close the cover of reservoir after the old one or conform to the CHERY’s specification. refilling. specifications. Please consult the CHERY Authorized Service Station for the correct...
Page 136 Maintenance and Care Check the wiper blade Replace the wiper blade Follow the correct tire pressure in case of high load and driving at high speed. The shortage of tire pressure may reduce the stability, increase the rolling resistance, and quicken the wear of tire, which may result the traffic accident and injured.
Page 137 Please the wheel is different from that of the The related regulations specify the depth contact the CHERY Authorized Service original one, it is difficult to display the of wear of the tire surface. Note that Station for other type tires and wheel proper speed of vehicle.
Page 138: Train Belts
(with the force of meet the requirement. For the sake of approx. 100N) check safety, please use CHERY’s original belt The cold or slightly warm water flexibility of the belt: is available only to clean your ONLY. The genuine spare belt is vehicle.
Page 139 If using the vehicle shampoo, please rinse sharp-edged articles to clean the cover. get to the CHERY Authorized Service the vehicle with a lot of clean water after Station to make it repaired, if necessary. the completion of washing. And then...
Page 140: Cleaning Products
Additionally, DO NOT polish neutral cleaning agent, such as soap the vehicle under strong sunshine. Please get to the CHERY Authorized foaming agent. During the normal service, After a period of traveling of a complete it is recommended to care the leather...
Page 141: Regular Maintenance Specifications
The pressure of air and water shall not exceed 150 KPa. The pressure of above 150 KPa may damage the radiator wings. Regular Maintenance Specifications Please drive your vehicle to the CHERY Authorized Service Station for regular maintenance according to the specified mileage. Mileage (Km) Maintenance Item...
Page 142 Maintenance and Care 5000 15000 30000 ★ ★ Lighting, warning flasher devices, horn: Check its performance ★ ★ Wiper and cleaning devices: Check its performance, and refill the cleaning fluid, if necessary ★ ★ Check the free travel and liquid level of clutch, and adjust it if necessary ★...
Page 143 Maintenance and Care Mileage (Km) Maintenance Item 5000 15000 30000 ★ ★ Wedge-shaped belt: Check its tension, and adjust or replace it, if necessary ★ ★ Transmission: Check its leakage or damage ★ ★ ★ Dust cap of constant velocity universal joint: Check its damage ★...
Page 144 Maintenance and Care Mileage (Km) Maintenance Item 5000 15000 30000 ★ ★ Control arm rubber sleeve: Check its damage ★ ★ Brake hose: Check its ageing, damage ★ ★ Brake pipe: Check its damage, corrosion and the leakage at any joint ★...
Page 145 Maintenance and Care Mileage (Km) Maintenance Item 5000 15000 30000 tightening torque of wheel bolt. ★ Tire position change ★ ★ ★ Chassis and body connecting bolt: Check its looseness, and tighten it, if necessary ★ ★ ★ Wheel: Check its looseness Engine idling check: Check whether the engine working condition of the engine, parameters of ★...
Page 146: First 5,000 Km Maintenance Card
Maintenance and Care First 5000km Maintenance Card (within 6 months as from purchase date) Owner: ___________________ First 2500km CHERY First 5,000 KM Company (Name):_________________ Date: ________________ Mileage: _______________ Maintenance Card Maintenance Address:________________________ Check items: Check itmes: Card 1. Check the leakage of lubrication, 11.
Page 147: Maintenance Record
Maintenance and Care □□ □□ □ □ 9. Check the effective work of brake 19. Check the working condition, wheel cylinder. eletronic fuel injector parameters and □ □ 10. Check whether the tire inflation exhaust of the engine while idling. pressure conforms to the specification.
Page 148 Maintenance and Care Regular Maintenance Regular Maintenance Up to 30,000 KM mileage or Up to 35,000 KM mileage or within six months after last within six months after last maintenance, implement maintenance, implement 30,000KM maintenance items 5,000KM maintenance items Date: ________________ Date: ________________ Mileage: _______________ Mileage: _______________...
Page 149 Maintenance and Care Regular Maintenance Regular Maintenance Regular Maintenance Up to 40,000 KM mileage or Up to 45,000 KM mileage or Up to 50,000 KM mileage or within six months after last within six months after last within six months after last maintenance, implement maintenance,...
Page 150 Maintenance and Care Regular Maintenance Regular Maintenance Regular Maintenance Up to 55,000 KM mileage or Up to 60,000 KM mileage or Up to 65,000 KM mileage or within six months after last within six months after last within six months after last maintenance, implement maintenance,...
Page 151 Maintenance and Care Regular Maintenance Regular Maintenance Regular Maintenance Up to 70,000 KM mileage or Up to 75,000 KM mileage or Up to 80,000 KM mileage or within six months after last within six months after last within six months after last maintenance, implement maintenance,...
Page 152 Maintenance and Care Regular Maintenance Regular Maintenance Up to 85,000 KM mileage or Up to 95,000 KM mileage or within six months after last within six months after last maintenance, implement maintenance, implement 5,000KM maintenance items 5,000KM maintenance items Date: ________________ Date: ________________ Mileage: _______________ Mileage: _______________...
Page 153: Warranty Service
2.---------------------------- 1.---------------------------- To ensure the normal operation of the 3.---------------------------- 2.---------------------------- airbag system, you shall get to the 4.---------------------------- 3.---------------------------- CHERY Authorized Service Station 5.---------------------------- 4.---------------------------- according to the specified time and 6.---------------------------- 5.---------------------------- have the airbag system replaced. 6.----------------------------...
Page 154 1.---------------------------- 2.---------------------------- 2.---------------------------- 2.---------------------------- 3.---------------------------- 3.---------------------------- 3.---------------------------- 4.---------------------------- 4.---------------------------- 4.---------------------------- 5.---------------------------- 5.---------------------------- 5.---------------------------- 6.---------------------------- 6.---------------------------- 6.---------------------------- Date: ------------------------ Date: ------------------------ Date: ------------------------ Seal of CHERY Authorized Seal of CHERY Authorized Seal of CHERY Authorized Service Station: Service Station: Service Station:...
Page 155 Capacity and Specification Parameters Chapter 12 Capacity And Specification Parameters...
Page 156: Vehicle Identification Direction
Capacity and Specification Parameters Vehicle Identification Direction Vehicle Data Plate...
Page 157: Fuel
Capacity and Specification Parameters Vehicle Data Plate Engine No The CHERY QQ6’s VIN code is engraved on the lower of gutter channel Number of SQR472F series engine is at front side of the vehicle (as shown in printed on the boss of cylinder body the figure below).
Page 158: Engine Oil
The fuel additives play recommended to contact the nearest which is excluded from the warranty CHERY Authorized Service Station a role in preventing the engine from immediately. scope. corroding and scaling, and cleaning the fuel system.
Page 159: Automobile Oil/Fluid
CHERY Authorized Service conditions. This kind of damage is Transmission oil NOT covered in this warranty. Station has the CHERY OEM oil/fluid stocked. Refill engine oil M/T (Manual Transmission) Brake fluid and clutch oil QR513MHA transmission oil employs CHERY...
Page 160: Windscreen Washer Fluid
Use the coolant that meets the CHERY The empty/scrap engine oil containers example), it shall be performed to specification. The CHERY Authorized and strainers shall not be disposed as...
Page 161 Capacity and Specification Parameters CAPACITY (L) Engine Oil SQR473F series: 3.5—4.0 L (Including strainer) SQR472F series: 3.5 L QR513MHA: 1.8± 0.1L M/T (Manual Transmission) QR512: 2.1L Power Assisted Steering MAX mark 1.3L displacement: 6.5 L Cooling System 1.1L displacement: 6.0 L Windscreen Cleaning MAX mark...
Page 162 Capacity and Specification Parameters Capacity Complete Vehicle Curb Mass Model SQR7130QQ6 SQR7110QQ6 Complete Vehicle Kerb Mass 1050 Complete Vehicle Front Axle kg Kerb Axle-Load Rear Axle kg Mass Maximum Manufacturer’s Load Maximum Manufacturer's Total Mass 1425 1365 Axle-load Mss at Front Axle kg Maximum Manufacturer's...
Page 163: Wheel And Tire
Capacity and Specification Parameters month, especially for the tire pressure during driving at high speed. Wheel and Tire  The pressure values listed in this table are applicable to the cold tire, and it is unnecessary to decrease the air Tire pressure pressure if it increases slightly after the tire is heated.
Page 164 Capacity and Specification Parameters...
Page 165: Engine Information
Capacity and Specification Parameters Engine Information Model SQR473F SQR472F Vertical, water-cooled, four-strokes, Vertical, water-cooled, four-strokes, in-line, double overhead camshaft, 4 in-line, double overhead camshaft, Type valves, multipoint electronic gasoline multipoint electronic gasoline injection injection Cylinder Diameter (mm) Piston Stroke (mm) 77.5 66.5 Displacement ml...
Page 166: Vehicle Dimension
Capacity and Specification Parameters The adjustment or inspection shall be conducted at least 5 minutes later after the engine stops operating. Vehicle Dimension...
Page 167 Capacity and Specification Parameters Item Dimension (mm) A=Max Length 3998 B=Full Width 1640 C=Full Height (Kerb Weight) 1535 D=Wheelbase 2340 1420 Front E=Wheel Track 1420 Rear ≥130 Ground Clearance...

Chery QQ6 Service Manual

Quick Links

Related Manuals for Chery QQ6

Summary of Contents for Chery QQ6

Table of Contents