BOMBARDIER ELAN 3042 1985 Shop Manual page 96

Section 02 ENGINE
Sub-section 04 (447 ENGINE TYPE)
ADJUSTMENT
Prior to adjusting the pump, make sure all carburetor
adjustments are completed .
To synchronize pump with carburetor:
Eliminate the throttle cable free-play by pressing the
throttle lever until a light res1stance is felt, then hold in
place. Th e aligning marks on the pump casting and on
the lever must align .
If not, loosen the adjuster nut and
adjust accordingly .
Retighten the adjuster nut .
A00100 2008
To bleed oil lines:
All oil lines should be full of oil. If required, bleed the main
oil line (between tank and pump) by loosen ing the blee-
der screw until all air has escaped from the line .
Make sure the tank is sufficiently filled.
Check the small oil lines I between pump and intake mani-
fold) . If requir ed, fill the lines by running the engine at
idle speed while holding the pump lever in fully open po-
sition .
A001002009
Fu lly open
pump lever
...A.
WARNING : Ensure not to operate carburetor throt-
T
tie mechanism : Secure the rear of the vehicle on a
stand.
02 -04-18
. e