Club Car 2007 Carryall 295 Maintenance And Service Manual page 557

INDEX
removal ..............................................................7-1
storage
vehicle storage ...................................................3-2
suspension, front
camber
adjustment ...................................................7-12
measurement ..............................................7-11
shock absorber
installation ...................................................7-19
removal ........................................................7-18
steering upright
installation ...................................................7-19
removal ........................................................7-13
toe-in adjustment .............................................7-11
toe-in measurement .........................................7-11
suspension, rear
shock absorber
installation .....................................................9-2
removal ..........................................................9-1
swing arm
installation .....................................................9-3
removal ..........................................................9-2
switch, auxiliary
installation ......................................................16-16
removal ..........................................................16-16
testing ............................................................16-15
switch, bed lift (diesel vehicles)
installation ......................................................12c-8
removal ..........................................................12c-8
switch, bed lift (gasoline vehicles)
installation .......................................... 12a-9, 12b-8
removal .............................................. 12a-9, 12b-8
switch, float
installation ......................................................16-15
removal ..........................................................16-15
testing ............................................................16-14
switch, joystick ON/OFF
installation ......................................................16-13
removal ..........................................................16-13
testing ............................................................16-12
switch, neutral (diesel vehicles)
installation ......................................................12c-2
removal ..........................................................12c-2
switch, neutral (gasoline vehicles)
installation .......................................... 12a-2, 12b-2
removal .............................................. 12a-2, 12b-2
T
12-volt accessory receptacle (diesel vehicles)
testing ..........................................................11c-44
12-volt accessory receptacle (gasoline vehicles)
testing ............................................ 11a-32, 11b-33
2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual
test procedures (diesel vehicles)
1 – battery ....................................................11c-13
2 – fuse ........................................................11c-16
3 – ground cables ........................................11c-17
4 – key switch (starter circuit) ......................11c-18
5 – key switch (on position) ..........................11c-19
6 – key switch (glow plug circuit) .................11c-19
7 – starter control circuit ...............................11c-20
8 – start relay ...............................................11c-21
9 – differential relay ......................................11c-22
10 – fan relay ...............................................11c-23
11 – thermostat switch .................................11c-25
12 – fan motor ..............................................11c-27
13 – wire harness diodes .............................11c-28
14 – neutral switch .......................................11c-35
15 – wire continuity ......................................11c-36
16 – front drive gearcase coil .......................11c-37
17 – alternator ..............................................11c-37
18 – fusible link ............................................11c-38
19 – temperature warning light circuit ..........11c-39
20 – glow plug circuit ...................................11c-40
21 – reverse buzzer limit switch ...................11c-41
22 – reverse buzzer .....................................11c-42
23 – fuel solenoid pull coil circuit .................11c-42
24 – fuel solenoid hold coil circuit ................11c-42
25 – fuel pump circuit ...................................11c-43
26 – low oil warning light ..............................11c-44
27 – 12-volt accessory receptacle ...............11c-44
28 – fuel level sending unit ..........................11c-45
29 – fuel gauge ............................................11c-46
30 – hour meter ............................................11c-48
31 – headlight switch ...................................11c-49
32 – voltage at headlight socket ..................11c-50
33 – bed lift motor ........................................11c-51
34 – bed lift switch .......................................11c-52
35 – bed lift circuit breaker ...........................11c-53
test procedures (hydraulic attachment vehicles)
accessory relay ..............................................16-18
auxiliary switch ...............................................16-15
circuit breaker ................................................16-20
float switch .....................................................16-14
joystick ...........................................................16-10
joystick ON/OFF switch ..................................16-12
relay ...............................................................16-17
solenoid ..........................................................16-19
test procedures (gasoline vehicles)
1 – battery .......................................... 11a-9, 11b-9
2 – fuse .......................................... 11a-12, 11b-12
3 – ground cables .......................... 11a-12, 11b-12
4 – key switch (starter circuit) ........ 11a-13, 11b-13
5 – key switch (accessory terminal) .............11b-14
6 – starter control circuit ................. 11a-14, 11b-15
Page i-9