Club Car 2007 Carryall 295 Maintenance And Service Manual page 185

TROUBLESHOOTING AND ELECTRICAL SYSTEM: KAWASAKI POWERED GASOLINE VEHICLES
2.1. Turn the key switch OFF and remove the key. Place the Forward/Reverse handle in NEUTRAL.
Chock the wheels.
2.2. Disconnect the battery as instructed. See WARNING "To avoid unintentionally starting..." in
General Warning, Section 1, Page 1-1.
2.3. Set the multimeter to 200 ohms.
2.4. Measure the resistance between the male side of the carburetor solenoid bullet connector and the
engine (ground) (Figure 11a-27, Page 11a-31). The resistance should be approximately 30 ohms.
2.5. If the resistance reading is incorrect, replace the solenoid coil. See the Kawasaki FH680D engine
manual (CCI P/N 103351201).
Figure 11a-27 Carburetor Solenoid Bullet Connector
TEST PROCEDURE 22 – LOW OIL WARNING LIGHT CIRCUIT
See General Warning, Section 1, Page 1-1.
If the low oil warning light stays on, test the oil pressure switch. See the Kawasaki FH680D engine manual
(CCI P/N 103351201). If the low oil warning light does not illuminate and the vehicle is low on oil, proceed to
step 1. See following NOTE.
NOTE: The low oil warning light should illuminate when the key switch is turned to the ON position. After
the engine has been started, the low oil warning light should remain illuminated until the oil pres-
sure switch has been activated.
1. Turn the key switch OFF and remove the key. Place the Forward/Reverse handle in NEUTRAL. Chock
the wheels.
2. Raise the hood.
3. Ensure that the wires on the oil warning light are connected correctly and are tight. If they are not, rewire
or tighten as necessary.
4. Disconnect the 18-gauge blue/white wire (w17) from the low oil warning light terminal.
5. Leave the 18-gauge purple wire (w42) connected to the low oil warning light.
6. Place a jumper wire on the terminal of the low oil warning light where the blue/white wire (w17) was
removed.
7. Touch the frame (ground) with the remaining end of the jumper wire.
8. Turn the key switch to the ON position. The low oil warning light should illuminate.
2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual
11A
Test Procedures
Page 11a-31