Club Car 2007 Carryall 295 Maintenance And Service Manual page 199

TROUBLESHOOTING AND ELECTRICAL SYSTEM: HONDA POWERED GASOLINE VEHICLES
TROUBLESHOOTING GUIDE
SYMPTOM
Loss of engine power.
Spark plug fouls repeatedly.
Carburetor floods.
Starter fails to operate.
Troubleshooting Guide continued on next page...
2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual
POSSIBLE CAUSES
Exhaust valve is restricted with carbon
deposit
Muffler or exhaust pipe restricted with
carbon or other substance
Ignition coil failure
Air filter is dirty or clogged
Governor is improperly adjusted
Throttle linkage out of adjustment
Low cylinder compression
Spark plug failed
Restricted fuel flow
Clutches are not backshifting properly
Incorrect plug
Unsuitable fuel, or incorrect (rich) fuel
mixture
Spark plug wire is damaged
Dirt entering combustion chamber
Ignition coil failed
Rings are heavily worn, low cylinder
pressure
Inlet valve or seat is leaking,
dirty, worn, or damaged
Float is damaged and filled with gasoline
Carburetor vent is clogged
Float needle valve not functioning
properly
Starter control circuit is
not operating
Start relay failure
Fuse is blown
Battery is dead
Charge coil failed
Troubleshooting Guide
REFER TO
See the Honda GX620 engine manual
(CCI P/N 102615401).
Exhaust System on page 13b-5
Test Procedure 15 – Ignition Spark on
page 11b-27
Air Filter Replacement on page 13b-24
Fuel System on page 13b-7
Engine Control Linkages on page 13b-16
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
Fuel System on page 13b-7
Clutches on page 13b-29
See the Honda GX620 engine manual
(CCI P/N 102615401).
Fuel System on page 13b-7
See the Honda GX620 engine manual
(CCI P/N 102615401).
Fuel System on page 13b-7
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
Test Procedure 6 – Starter Control Circuit
on page 11b-15
Test Procedure 7 – Start Relay on
page 11b-16
Test Procedure 2 – Fuse on page 11b-12
Test Procedure 1 – Battery on page 11b-9
Test Procedure 13 – Charge Coil on
page 11b-26
11B
Page 11b-3