Club Car 2007 Carryall 295 Maintenance And Service Manual page 447

DIESEL ENGINE, MUFFLER, FUEL SYSTEM, AND CLUTCHES
Figure 13c-13 Diesel Fuel Tank
11. Disconnect the black wire and orange wire from the fuel level sensor on the tank. Do not remove the
lower nut on the center stud of the sensor.
12. Remove the nut from the fuel tank strap below the passenger seat area.
13. Lift the strap end and remove the opposite end from the slotted bracket.
14. Remove the passenger-side bed latch bracket from the frame.
15. Remove the fuel tank.
Fuel Tank Storage or Disposal
1. Remove the cap from the tank and thoroughly rinse it with water. The cap may be discarded or kept as
a spare.
2. Use a well-ventilated area and flush the fuel tank with water to remove any remaining fuel.
3. Set the tank upside down in a well-ventilated area so that the water can drain. Allow the tank to sit for 24
hours to dry. See following WARNING.
ý
WARNING
• Dispose of wastewater and fuel tank in accordance with federal, state, and local laws and
ordinances.
4. Store the tank upside down with the cap installed in a well-ventilated area.
Fuel Tank Installation
1. Place the fuel tank in the vehicle.
2. Insert the tab end of the strap into the frame bracket and place the strap in the indentions on the tank.
3. Feed the threaded tab end down into the bottom of the frame. Install a nylon locknut and tighten the nut
to 40 in-lb (4.5 N·m).
4. Connect the clear vent tube to the fuel tank vent and secure the tube with a new clamp.
5. Connect the fuel line to the primary fuel filter on the vehicle frame and secure it with a new clamp.
2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual
13C
Fuel System
Page 13c-17