Club Car 2007 Carryall 295 Maintenance And Service Manual page 197

SECTION 11B – TROUBLESHOOTING AND
ELECTRICAL SYSTEM: HONDA POWERED
GASOLINE VEHICLES
ý
DANGER
• See General Warning, Section 1, Page 1-1.
ý
WARNING
• See General Warning, Section 1, Page 1-1.
TROUBLESHOOTING GUIDE
The following troubleshooting guide will be helpful in identifying operating difficulties should they occur. The
guide includes the symptom, probable cause(s) and suggested checks.
TROUBLESHOOTING GUIDE
SYMPTOM
Engine does not start easily.
Troubleshooting Guide continued on next page...
2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual
POSSIBLE CAUSES
Spark plug is partially fouled or in poor
condition
Spark plug wire is damaged or loose
Intermittent ignition coil failure
Low cylinder compression
Water or dirt in the fuel system
and/or carburetor;
dirty or clogged fuel filter
Carburetor improperly adjusted
Starter failure
Carburetor solenoid failure
Diode 2 failed open
Diode 3 failed open
REFER TO
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
Fuel System, Section 13b, Page 13b-7
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
Test Procedure 21 – Carburetor Solenoid
Circuit on page 11b-31
Test Procedure 9B – Diode 2 on wire 40
on page 11b-20
Test Procedure 9C – Diode 3 on wire 45
on page 11b-21
Page 11b-1
11B