Honda Civic 2002-2003 Service Manual page 31

-
•
•
Do the items in parts A, B
t
C, D, and E as required for mileage/time interval listed.
A
B
Replace engine oil (see page 8-5), -Capacity without filter change: 4.0
Q,
(4.2 US qt, 3.5 Imp qt)
Rotate tires. Follow the pattern shown in the Owner's Manual --Check tire information and condition.
Replace engine oil filter (see page 8-6), -Capacity with filter change: 4.2ft {4.4 US qt, 3.7 Imp qt}
Inspect front and rear brakes (see page 19-3),
• Check pads and discs for wear (thickness), damage, and cracks.
• Check calipers for damage, leaks, and tightness of mount bolts.
Check parking brake adjustment. Should be fully applied within 7 to 9 clicks.
Inspect tie-rod ends, steering gearbox, and boots (see page 17-5),
• Check rack grease and steering linkage.
• Check boots for damage and leaking grease.
• Check fluid line for damage and leaks.
Inspect suspension components.
• Check bolts for tightness.
• Check condition of ball joint boots for deterioration and damage.
Inspect driveshaft boots. Check boots for cracks and boot bands for tightness (see page 16-3).
Inspect brake hoses and lines {including ABS}. -Check the master cylinder, proportioning control valve, and ABS modulator for damage
and leakage.
Check all fluid levels and condition of fluids; check for leaks. If necessary, add MTF (see page 13-3), engine coolant, brake fluid, and
windshield washer fluid.
L I Inspect exhaust system*. Check catalytic converter heat shield, exhaust pipe and muffler for damage, leaks, and tightness (see page 9-8).
I I Inspect fuel lines and connections*. Check for loose connections, cracks and deterioration; retighten loose connections and replace
damaged parts (see page' 1-146).
C
I Inspect and adjust drive belt.
o
• Look for cracks and damage, and inspect auto tensioner (needs no adjustment).
Replace the dust and pollen filter (see page 21-39) .
• Replace the dust and pollen filter whenever airilow from the heating and cooling system is less than normal.
I Replace air cleaner element every 30,000 miles (48,000 km) (independent of time).
E
J
Replace brake fluid every 3 years (independent of mileage).
According to state and federal regulations, failure to do the maintenance items marked with asterisk{ *) will not void customer's emissions
warranties. However, Honda recommends that all maintenance service be done atthe recommended interval to ensure long-term reliability .
3-5