Exterior Lights
Daytime Running Lights Control Unit Input Test (cont'd)
4. Make these input tests at the connector.
• If any test indicates a problem, find and correct the cause, then recheck the system.
• If all the input tests prove OK, the control unit must be faulty; replace it.
Cavity
Wire
1
RED/ORN
11
RED/WHT
2
RED/BLU
4
BLK
7
6
GRN/WHT
8
BLU/RED
9
BLU/WHT
10
RED/YEL
3
ORN/WHT
5
12
YEL/RED
13
GRN/RED
22-128
Test condition
Combination light
Connect a jumper wire between
switch ON (
),
No. 1 and No. 2 terminals and
and dimmer switch
connect No. 11 terminal to
in HIGH
ground:
The headlights (HIGH) and high
beam indicator light should
come on.
Under all
Check for voltage to ground:
conditions
There should be battery voltage.
Under all
Check for continuity to ground:
conditions
There should be continuity.
Parking brake
Check for continuity to ground:
pedal pressed
There should be continuity.
Headlights OFF
Check for voltage to ground:
There should be battery voltage.
Ignition switch ON
Connect to ground:
(II)
The indicator light should come
on.
Combination light
Check for voltage to ground:
switch ON (
),
There should be battery voltage.
and dimmer switch
in HIGH
Combination light
Check for continuity to ground:
switch ON (
)
There should be continuity.
Ignition switch ON
Check for voltage to ground:
(II)
There should be battery voltage.
Brake fluid
Check for continuity to ground:
reservoir float in
There should be continuity.
down position
Test: Desired result
Possible cause if result is not
obtained
•
Blown No. 55 (40A) fuse in
the under-hood fuse/relay
box
•
Blown No. 6 (10A) fuse in the
passenger's under-dash fuse/
relay box
•
Blown headlight bulb (High
beam)
•
Blown high beam indicator
light
•
An open in the wire
•
Poor ground (G401)
•
Blown No. 55 (40A) fuse in
the under-hood fuse/relay
box
•
Blown No. 6 (10A) fuse in the
passenger's under-dash fuse/
relay box
•
An open in the wire
•
Poor ground (G401)
•
An open in the wire
•
Faulty parking brake switch
•
An open in the wire
•
Faulty headlight relay 1
•
An open in the wire
•
Faulty DRL indicator light
•
An open in the wire
•
Blown No. 45 (15A) fuse in
the under-hood fuse/relay
box
•
Faulty combination light
switch
•
Faulty headlight relay 2
•
An open in the wire
•
Faulty combination light
switch
•
Poor ground (G401)
•
An open in the wire
•
Blown No. 5 (7.5A) fuse in the
driver's under-dash fuse/relay
box
•
An open in the wire
•
Faulty brake fluid level switch
•
An open in the wire
•
Poor ground (G302)