Mazda 1990 323 Workshop Manual Supplement page 20

PRE-DELIVERY INSPECTION
PRE-DELIVERY INSPECTION
PRE-DELIVERY INSPECTION TABLE
INSPECT and ADJUST, if necessary, the following items to
the specifications:
0 Glass, exterior bright metal and paint for damage
Cl Wheel lug nuts
88-l 18 N.m (9-l 2 m-kg, 65-87 ft-lb)
Cl Tire pressures (Refer to section Q)
q
All weatherstrips for damage or detachment
I? Operation of hood release and lock
0 Operation of trunk lid, back door, and fuel lid opener
0 Door operation and alignment
0 Headlight aiming
INSTALL the following parts:
0 Wheel caps or rings (if equipped)
0 Outside rear view mirror(s)
1 UNDER HOOD-ENGINE OFF ]
INSPECT and ADJUST, if necessary, the following items to
the specifications:
Cl Fuel, coolant and hydraulic lines, fittings, connections and
components for leaks
0 Engine oil level
Cl Power steering fluid level
0 Brake and clutch master cylinder fluid level
ci Windshield washer reservoir fluid level
0 Radiator coolant level and specific gravity
~1
0 Tightness of water hose clamps (including heater hoses)
0 Tightness of battery terminals
0 Manual transaxle oil level
Cl Drive belt tensions
0 Accelerator cable and its linkage for free movement
CLEAN spark plugs
piteiiq
INSTALL the following parts:
0 Rubber stopper for inside rear view mirror
q
Fuse for accessories
CHECK the operations of the following items:
Seat controls (sliding,and reclining) and head restraint
Folding rear seat
Door locks including childproof door locks (if equipped)
Seat belts and warning system
Ignition switch and steering lock
Inhibitor switch (ATX only)
Starter interlock switch (clutch pedal, MTX only)
All lights including warning and indicator lights
Sound warning system
Horn, wipers and washers (front and rear, if equipped)
0 Audio system (if equipped)
0 Cigarette lighter and clock
0 Heater, defroster and air conditioner at various mode
selection (if equipped)
CHECK the following items:
0 Presence of spare fuse
cl Upholstery and interior finish
CHECK and ADJUST, if necessary, the following items:
II Operation and fit of windows
El Pedal height and free play of brake and clutch pedal
Pedal height mm (in) Free play mm (in)
Clutch pedal
'Q8yg
y$$03) 5-13 (0.197-0.512)
I
Brake pedal 1193-196 (7.60-7.72)1 4-7 (0.16-0.28) 1
q
Parking brake
5-7 notches198 N (10 kg, 221b)
UNDER HOOD-ENGINE RUNNING AT
OPERATING TEMPERATURE
CHECK the following items:
0 Automatic transaxie fluid level
0 Initial ignition timing (with TEN terminal of diagnosis con-
nector grounded)
5 f 1 o BTDC: BP SOHC
0 Idle speed (ATX: P range, MTX: Neutral)
750 * 50 rpm: (With parking brake applied)
1 ON HOIST 1
CHECK the following items:
0 Underside fuel, coolant and hydraulic lines, fittings, con-
nections and components for leaks
0 Tires for cuts or bruises
0 Steering linkage, suspension, exhaust system and all un-
derside hardware for looseness or damage
1 ROAD TEST 1
CHECK the following items:
Brake operation
Clutch operation
Steering control
Operation of meters and gauge
Squeaks, rattles or unusual noise
Engine general performance
Emergency locking retractors
Cruise control system (if equipped)
1 AFTER ROAD TEST 1
REMOVE seat and floor mat protective covers
CHECK for necessary owner information materials, tools and
spare tire in vehicle
03UOAX-801
A-2