Storage; Putting The Vehicle Into Operation After Storage - KTM 450 SX ATV 2010 Repair Manual

STORAGE

Storage
38.1
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
–
Avoid contact between fuel and skin, eyes and clothing. Do not inhale fuel vapors. If fuel gets into your eyes, rinse immedi-
ately with water and contact a doctor. Wash affected skin areas immediately with soap and water. If fuel is swallowed, con-
tact a doctor immediately. Change clothing that has come into contact with fuel. Store fuel in a suitable canister according
to regulations and keep it out of the reach of children.
Info
If you want to store the vehicle for a longer period, take the following actions.
Info
Before storing the vehicle, check all parts for function and wear. If service, repairs or replacements are necessary, you should
do this during the storage period (less workshop overload). In this way, you can avoid long workshop waiting times at the start
of the new season.
–
Clean the vehicle. ( p. 215)
–
Change the engine oil and oil filter, clean the oil screen. (
–
Check the antifreeze and coolant level. (
–
Drain the fuel from the tank into a suitable container.
–
Drain the carburetor float chamber. (
–
Check the tire air pressure. (
–
Remove the battery. ( p. 83)
–
Recharge the battery. (
Guideline
Storage temperature of battery without direct sunshine
–
Store the vehicle in a dry location that is not subject to large fluctuations in temperature.
–
Cover the vehicle with a tarp or cover that is permeable to air.
Info
Do not use non-porous materials since they prevent humidity from escaping, thus causing corrosion.
Avoid running the engine of a vehicle in storage for a short time only. Because the engine will not warm up sufficiently, the
water vapor produced during combustion will condense, causing engine parts and the exhaust system to rust.

Putting the vehicle into operation after storage

38.2
–
Install the battery. ( p. 83)
–
Fill up with fuel.
–
Checks before putting into operation
–
Make a cautious test ride.
p. 180)
p. 164)
p. 72)
p. 84)
p. 183)
0... 35 °C (32... 95 °F)
216