Volvo Ingersoll Rand SD-116 TF Series Operator's Manual page 46

SECTION 1
7. Checklist
1-22
PRE-STARTING
Hoses, Safety Shrouds
Muffler, Engine
Railings, Fittings - INSPECT FOR DAMAGE
Fluid Levels - CHECK
DO NOT OPERATE FAULTY EQUIPMENT
STARTING
CONSULT OPERATOR'S INSTRUCTION MANUAL -
SEE YOUR SUPERVISOR.
Propulsion Control Lever - CHECK IN STOP POSITION
Engine Speed - LOW IDLE
N/MIN
Parking Brake - APPLY TO ALLOW ENGINE STARTING
P
Emergency Stop Switch - RESET =
STOP
Work Area - CLEAR
STOP Ignition Switch- ON =
- BRAKE LIGHT - VERIFY ON
- START = (30 seconds MAX.)
N O T E :
O p e r a t o r m u s t b e s e a t e d
w h i l e s t a r t i n g e n g i n e .
OPERATING
Articulation Lock Pin - REMOVE AND STOW
Seat Belt - FASTEN
Engine Speed - HIGH (Operating) IDLE
N/MIN
N O T E :
P Parking Brake - RELEASE =
T e s t b r a k e s d a i l y .
( P r o c e d u r e i n m a n u a l )
N O T E :
E n g i n e w i l l s t o p w i t h i n f i v e
s e c o n d s w i t h o p e r a t o r o f f
s e a t .
Propulsion Control Lever: - Move SLOWLY:
- Move to STOP for
NORMAL BRAKING
Vibration Control - ENGAGE ONLY WHEN IN MOTION
MAN AUTO
Select Vibration modes: or
Vibration Frequency - Select required Frequency
Operation:
Operating - STAY SEATED
- ALLOW NO PASSENGERS
- ALLOW NO BYSTANDERS
Downhill and Uphill Travel - GO SLOWLY
SHUTDOWN
Machine: - ON LEVEL SURFACE AND PROPULSION
CONTROL LEVER IN STOP POSITION.
Water / Emulsion Spray Switch - OFF =
Vibration Mode Selector - OFF =
Parking Brake - APPLY
P
Engine Speed - LOW IDLE (For 3-4 mins.)
N/MIN N o t e :
Ignition Switch - OFF = D i s m o u n t i n g m a c h i n e w i t h
STOP
e n g i n e r u n n i n g i s p e r m i s s i b l e .
STOP
F o l l o w t h e s t e p s f o r s h u t d o w n
e x c e p t d o n o t s w i t c h i g n i t i o n
o f f . P a r k i n g b r a k e m u s t b e
a p p l i e d o r e n g i n e w i l l s h u t o f f .
TRANSPORT
Hauling:
Articulation Lock Bar - LOCK
Machine - CHOCK
- TIE DOWN SECURELY TO TRAILER
Towing:
DO NOT TOW UNTIL YOU REFER TO
OPERATOR'S INSTRUCTION MANUAL
SWG
SD-116F/DX/122D/F/DX/160F/DX/190DX/200F/DX
F R
13197306.01
SAFETY