Toro Groundsmaster 3280-D Service Manual page 79

Removing the Engine (continued)
Groundsmaster ® 3280-D/3320
05138SL Rev B
C. Cover or plug the fuel hoses and pump fittings openings to prevent
contamination. Position the disconnected hoses away from the engine.
14. Remove the hydraulic pump/transmission driveshaft; refer to
Hydraulic Pump Driveshaft (page 5–97)
Driveshaft (page 5–87).
15. Remove the cotter pin and clevis pin that secure the hood cable to the muffler
mount. Support the hood in open position.
To prevent damage to the electrical wire harness, numerous cable
ties are used to secure the wire harness to the machine components.
Record the location of all cable ties that are removed from the
machine during the engine removal so that they can be properly
replaced during the engine installation.
16. For assembly purposes, note the location of the cable ties used to secure
the wire harness to the machine. Disconnect the wires and/or electrical
connections from the following engine electrical components:
A. Alternator connector and stud.
B. Oil pressure switch located near the engine oil filter.
C. Connector, fusible link connector, and positive battery cable from the
starter motor.
D. High temperature shut down switch and temperature sender located on
the water pump housing.
E. Fuel stop solenoid on the injector pump.
F. Negative battery cable from the injector pump.
G. Glow plug strip.
H. PTO clutch wire connector.
The engine is very heavy, and a hoist not rated for the weight of the
engine may fail, causing possible injury and damage to the engine.
Use hoist equipment rated to lift the engine, which is approximately
93 kg (205 lb).
17. Attach a suitable lift or hoist to the lift tabs on the front and rear of the engine.
Support the engine with lift or hoist to prevent the engine from shifting or
moving.
18. Remove the fasteners that secure the engine (with brackets) to the engine
shock mounts and engine mount brackets
Use 1 person to operate the lift or hoist while the other person
guides the engine from the machine.
or
IMPORTANT
CAUTION
(Figure
CAUTION
Page 4–23
Removing the
Removing the Transmission
28).
Diesel Engine: Service and Repairs