Toro Groundsmaster 3280-D Service Manual page 54

Installing the Engine (continued)
Gasoline Engine: Service and Repairs
One person should operate lift or hoist while the other person
guides the engine into the machine.
Ensure not to damage the engine, fuel hoses, hydraulic lines,
electrical harness, or other parts while installing the engine.
C. Lower engine to the machine frame. Ensure that the engine bracket holes
are aligned with the holes in the engine shock mounts.
D. Secure engine to the engine mounts.
7. Install clevis pin and cotter pin to secure hood cable to muffler bracket.
8. Connect transmission driveshaft to engine pulley; refer to
Transmission Driveshaft (page
9. Reconnect all wire harness connectors to engine components.
10. Remove plugs installed in hoses during disassembly. Connect hoses to
the engine.
A. Connect fuel hose to the carburetor inlet fitting. Secure with hose clamp.
B. Connect upper and lower radiator hoses to the engine. Secure with hose
clamps.
11. Position throttle and choke cables to engine governor levers
Secure cables to governor bracket with cable clamp and screw. Adjust
cables; refer to Adjust Throttle Control (page 3–6)
(page 3–6).
12. Install air cleaner; refer to
Ensure that the clutch pulley and PTO pulley are aligned during PTO
shaft installation.
13. Install PTO shaft to machine; refer to
14. Position fan shroud to radiator. Ensure that a minimum of 6.4 mm (0.250
inch) clearance exists at all points between shroud and fan. Secure fan
shroud to radiator with 4 bolts, 4 flat washers, and 4 locknuts.
15. Install coolant reservoir to bracket on radiator fan shroud
overflow hose to radiator fill opening and secure with hose clamp.
16. Add coolant to radiator; refer to the Traction Unit Operator's Manual.
Note: Ensure to attach negative battery cable as battery base is installed.
17. Position battery base to brackets and secure with bolts and flange nuts
(Figure 16).
CAUTION
IMPORTANT
5–89).
Installing the Air Cleaner (page
IMPORTANT
Installing the PTO Shaft (page
Page 3–20
Installing the
(Figure 18).
and Adjust Choke Control
3–12).
9–9).
(Figure 17). Install
Groundsmaster ® 3280-D/3320
05138SL Rev B