Fuel Tank And Throttle Cable - BOMBARDIER ski-doo Tundra Scandic 2004 Series Shop Manual

FUEL TANK AND THROTTLE CABLE

Fuel Tank Lines
WARNING
When draining a fuel tank or whenever a fuel
line is disconnected, obstruct line with a hose
pincher (P/N 295 000 076) or equivalent device.
Fuel is flammable and explosive under cer-
tain conditions. Ensure work area is well ven-
tilated. Do not smoke or allow open flames or
sparks in the vicinity.
A01B2JA
Impulse/Fuel Lines Spring Clips
All Models
Always reposition spring clips after any repair to
prevent possible leaks.
Throttle Cable Circlip at Handlebar
All Models
Put silicone grease (P/N 293 550 004) around cable
barrel. Locate circlip as per illustration.
MMR2004-121_04_12A.FM
Subsection 12 (FUEL TANK AND THROTTLE CABLE)
295 000 076
TYPICAL
1. Throttle cable housing
2. Throttle lever housing
3. Throttle lever
4. Circlip
Adjust throttle cable as specified in CARBURETOR
AND FUEL PUMP.
Throttle Cable Routing
CAUTION: Check that throttle cable is routed
away from sharp edges, hot or vibrating parts.
When turning handlebar while engine is run-
ning, idle speed must not vary.
Section 04 ENGINE
WARNING
If this procedure is disregarded, throttle lever
might be half-open at normally closed position
and the engine will speed up when starting.
2
1
A02C0FA
0
3
4
04-12-1