Storage; Cooling System, Track, Suspension, Skis, Controls, Chaincase, Fuel Tank, Carbure- Tor, Cylinder Lubrication, Drive Pulley, Chassis, Battery, General Inspection - BOMBARDIER EVEREST Operator's Manual

STORAGE
+
W A RNING: Only perform such
procedures as detailed in this
manual. It is recommended that dealer
assistance be periodically obtained on
other components/systems not cov-
ered in this manual. Unless otherwise
specified, engine should be turned OFF
for all lubrication and maintenance pro-
cedures.
Cooling System (UC models)
The complete engine cooling system
should be drained and refilled with a
new coolant mixture.
+
W A RNING: Never drain or refill
the cooling system when the en-
gine is hot.
To drain the cooling system, siphon
the coolant mixture from the coolant
tank, using a primer pump and a length
of plastic hose and steel tubing inserted
as deep as possible into the lower hose
of the tank.
+
W A RNING: Use a PRIMER PUMP
to siphon the coolant mixture. Do
not siphon with your mouth. The cool-
ant mixture is poison and can be fatal if
swallowed.
4.54
liters
160 Imp. ounces ......
1........ . . -......
154 U.S. ounces
When the coolant level is low enough,
remove the engine filler plug.
30
. , CAUTION: To prevent rust for-
~
mation in the cooling system, al-
ways replenish the system with the re-
commended solution (60% antifreeze
40% water).
To refill the cooling system:
Remove engine filler plug.
~;;:;;::--:iiiiiii--iiiiiiiii;iiiii Filler plug-
Refill tank until coolant overfills at
filler hole.
Reinstall filler plug.
Continue to pour the liquid in the
coolant tank until level reaches 2.5 mm
(1") below filler neck.
Reinstall tank cap and start engine; let
engine run until it reaches its operating
temperature and thermostat opens. AI-
low it to run a few minutes more. Stop
engine and check coolant level, refill as
necessary.
+
W A RNING: Before removing the
cap place a cloth over the coolant
tank and release the cap to the first
step to release the pressure. Loss. of
fluid and possibility of severe burns
could occur, if this notice is disre-
garded.