Evinrude E-TEC E40DRLSCB Service Manual page 346

INDEX
Pressure Relief Valve 191, 197
Thermostat 11, 192
Thermostats 192, 196
Turbulence 39
Vapor Separator 159
Water Intake Screens 68, 69, 285
Water Pump 191, 278
Corrosion
Anodes 67, 245, 281, 290
Cylinder walls 210
Long Term Storage 77
Metal components 67
Steering Cable 69
Cover Service 82
Crankcase
Assembly 221
Disassembly 205
Crankshaft
Assembly 213, 218
Disassembly 207
Inspection 211
Crankshaft Position Sensor
Description 91
Operation Test 110
Resistance Test 124
Cylinder Bore
Honing 210
Inspection 211
Cylinder Head
Inspection 211
Installation 217
Removal 206
D
n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n
Dash Connections 120
Deutsch Connector Servicing 148
Diagnostic Procedures
Dynamic Tests 106
Fuel Delivery Tests 114
Ignition Tests 109
LED Indicators 107
Strategy 104
I–2
Diagnostic Software
Break-In Programming 56, 59, 182
CANbus Activation 52
Communication With Outboard 95
Crankshaft Position Sensor 110
Cylinder Drop Tests 106
Fuel Injector Programming 100, 169
Fuel Injector Tests 114
Fuel Pump Test 114
Idle Speed Control 99
Oil Injector Test 183
Oil Priming 56, 187
Oiling Rate 55, 56, 98
Reports 100
Sensor Monitoring 124
Service Codes 96
Static Ignition Test 111
Timing Verification 99, 143
TPS Calibration 99, 143
Driveshaft
Installation 294
Removal 283
Shimming 292
Driveshaft Bearing Housing 289
Dual-Outboard
Alignment 64
CANbus Setup 52
Centerlines 40
E
n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n n
Electrical Circuits
EMM Pin Locations 121
Fuse 123
Ground Circuits 123
Key Switch 131
Start Circuit 129
SystemCheck 136
Electrical Connectors
AMP Connectors 149
Deutsch Connectors 148
Packard Connectors 151
Electrical Harness Connections 50
Emergency Stop Switch
Installation 26
Operation Check 58