Errors Requiring Reboot - MUTOH ValueJet 1304 Service Manual

VJ-1304 Maintenance Manual
Table 9-3 Events and Check Items for Errors with Messages (Continued)
No. Message
6 Warning: Waste fluid
Waste fluid tank is almost
box full full.
7 Warning: Ink Ink tube life
tube life has almost
expired.
NOTE
• The square bracket pair in an error message contains the applicable ink color.
• If no ink and no cartridge occur at the same time, no cartridge message has priority to be displayed.
9.2.3

Errors Requiring Reboot

This section describes the contents of reboot-requiring errors as well as the check items and recovery actions.
These errors are issued when any of the following critical problems occurs.
• Obstacle that prevents the machine's operation
• Damage of electric circuits (boards, motors, sensors)
• Abnormal operation of control programs
When any of the above conditions occurs, the machine follows the steps shown below before stopping its
operation.
1. Turn OFF the driving system power automatically.
2. Flash all lamps in the operation panel and generate intermittent audible alarm.
3. Display the applicable error message on the LCD.
The error can be cancelled by removing the error causes and restarting the machine.
CS9050, CS9150
Event/ Check item
symptom
1. Turn machine OFF.
Turn it ON again
and check if the
same message
appears.
2. Waste ink in waste
fluid box reaches
full level.
1. Turn machine OFF.
Turn it ON again
and check if the
same message
appears.
2. Use of ink tube has
exceeded specified
level.
9-9
9 Troubleshooting
Action
If the message appears: -
Refer to the action in
check item No. 2.
Replace waste fluid box.
Manual
If the message appears: -
Refer to the action in
check item No. 2.
Replace ink tube.
Replacing
Ink Tube"
p.4-86
Reference
Operation
"4.10.2
Rev.-01