Table of Contents
Advertisement
www.WorkshopManuals.co.uk
Section D
70 - 2
Removal and Replacement
Cab Heater Controls
The cab heater controls A and associated cables are housed
in the R.H. side console as shown.
There are two control cables which operate the re-circulation
vent and the hot water valve. Both the cables can be
accessed by removing the side console instrument panel.
Removal
1
Park the machine on firm level ground, apply the
parking brake. Lower the loader arms and excavator to
the ground, switch OFF the engine and remove the
starter key.
2
Remove the fixing B at the top of the instrument panel
and carefully lift the panel forward to reveal the
connections at the back.
3
Disconnect the temperature control cable C by
releasing the cable outer sheath from the clips R at
each end, and unhooking the cable from the water valve
lever S and from the pin T at the control knob.
4
Disconnect the re-circulation vent cable D by releasing
the cable outer sheath from the clips X at each end, and
unhooking the cable from the vent Y and from the pin Z
at the control knob.
Replacement
Replacement is the reverse of the removal sequence.
After fitting the cables, operate the heater controls and
check that they function correctly.
Adjustment
If the control cable C is not correctly assembled it is possible
that the heater cannot be turned fully off.
To ensure that the heater can be turned fully OFF, the
temperature control cable C should be adjusted so that the
water valve will close FULLY within the range of movement
of the control knob as follows:
1
Set the water valve control lever S to the fully closed
position.
2
Turn the heater control knob E a small amount
clockwise from the closed position, i.e. a fraction before
the cold position on the decal as shown.
3
Tighten the cable clips R to clamp the cable outer
sheath.
4
Check the heater control range of movement and that
the water valve can be fully closed by turning the knob.
9803/3280
Controls
Control Cables
Purchased from www.WorkshopManuals.co.uk
Section D
70 - 2
B
A
A394410
Issue 1
Advertisement
Table of Contents
