Skoda Octavia II 2004 Workshop Manual page 74

Octavia II 2004 ➤ , Octavia II 2010 ➤ , Superb II 2008 ➤ , Superb II 20 ...
Propshaft and rear final drive - Edition 10.2018
Tightening torques
Component
Retaining strap for the heat shield of
1
the fuel tank
Propshaft to rear final drive
Rear final drive to assembly carrier
Exhaust System
Pendulum support to gearbox
1)
Replace screws after removal ⇒ Electronic Catalogue of Orig‐
inal Parts .
2.2.2 Removing and installing final drive 0BR,
Octavia II, Superb II, Yeti
Special tools and workshop equipment required
♦ Engine/gearbox jack , e.g. -V.A.G 1383A-
♦ Socket - T10061-
♦ Counterholder - T10172-
♦ Adapter - T10172/5-
In Yeti vehicles with rear final drive 0BR, generation IV four-wheel
drive clutch was installed up to production date 10/2013. From
production date 11/2013, the generation V four-wheel drive clutch
is installed. Assignment ⇒ Electronic Catalogue of Original Parts
Removing
– Remove luggage compartment floor covering.
– Remove the two rubber plugs -arrows A- in the luggage com‐
partment floor.
– Release both screws -arrow B- for the rear final drive to the
assembly carrier from the top through the holes in the luggage
compartment floor. Thus, the socket insert - T10061- can be
used.
– Raise vehicle.
– Remove the rear silencer ⇒ Engine; Rep. gr. 26 .
– Remove mounting bracket of exhaust system from assembly
carrier ⇒ Engine; Rep. gr. 26 .
– Tie up pre-exhaust pipe.
NOTICE
Risk of damage to the decoupling element of the exhaust sys‐
tem.
The decoupling element must not be bent or kinked by more
than 10°.
– Do not load the decoupling element with tensile stress.
– Do not bend the decoupling element excessively.
– Remove the heat shield below the propshaft.
70
Rep. gr.39 - Final drive - rear differential
⇒ "1.1 Summary of components - propeller shaft", page 16
1
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by ŠKODA AUTO A. S. ŠKODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by ŠKODA AUTO A. S.
Nm
25
⇒ Chassis; Rep. gr. 42
⇒ Engine; Rep. gr. 26
⇒ Engine; Rep. gr. 10