Engine Intake Pre-Filter Screen Service; Air Filter Service - Polaris RANGER XP 900 2018-2019 Service Manual

MAINTENANCE
ENGINE INTAKE PRE-FILTER SCREEN
SERVICE
It is recommended that the engine intake pre-filter be
inspected daily. The filter should be inspected using the
following procedure:
1. The engine intake pre-filter is located just behind the
driver hip bolster on the left side of the vehicle. The
pre-filter is adhered to the back of the body panel.
2. Inspect the pre-filter. Wipe away any deposits with a
clean cloth.
3. If necessary, remove the body panel and clean the
pre-filter with soapy water and dry with low pressure
compressed air.

AIR FILTER SERVICE

Inspect the air filter at the intervals outlined in the
Periodic Maintenance
conditions, air filter replacement will be required more
often.
1. Tilt the rear cargo box to access the airbox.
2. Release the (5) airbox cover latches and lower the
bottom cover to access the air filter element.
2.26
Chart. In extremely
3. Remove the air filter element
Leave the front portion of the lower airbox cover in the
hinges. It is not necessary to remove the lower cover
when servicing the air filter.
4. Inspect the airbox for oil or water deposits. Wipe
away any deposits with a clean shop towel.
If the filter has been soaked with fuel or oil it must be
5. Inspect the air filter and replace if necessary.
dusty
DO NOT attempt to clean the air filter.
6. Place the air filter into the airbox. Reposition the
lower airbox cover and install the five retaining
latches.
Make sure the hinge pins are properly seated when
9929399 R01 - 2018-2019 RANGER XP/ CREW 900/1000 Service Manual
q
.
NOTICE
NOTICE
replaced.
NOTICE
NOTICE
reassembling the airbox
© Copyright Polaris Industries Inc.