Maintenance Intervals - Polaris Sportsman XP 1000 S 2020 Service Manual

MAINTENANCE INTERVALS

The maintenance interval charts outline required maintenance and inspection based on vehicle hours / miles. Each
table states the number of hours / miles that service is required on the vehicle. Some items or components may need
to be serviced more often due to severe use, such as operation in water or under severe loads. When the vehicle goes
beyond 500 hours / 5000 miles, return to the 25 hours / 250 mile chart and start the interval process over, disregard
any break-in services.
The following symbols denote potential items to be aware of during maintenance:
• XU Perform these procedures more often for vehicles subjected to severe use.
• D Have an authorized Polaris dealer perform these services.
• E Emission Control System Service (California)
ITEM
XU / D Brake Pad Wear
Engine Oil
XU
XU Front / Rear Gearcase Fluid
Fuel System Check
XU
XU Transmission Fluid
ITEM
Battery
XU / D Brake Pad Wear
Engine Oil
XU
XU Front / Rear Gearcase Fluid
Front / Rear Suspension
XU
Fuel System Check
XU
XU General Lubrication
Radiator
Shift Linkage
XU Shock Absorbers
Steering
D
Throttle Body Intake Duct
E
XU Throttle Cable
XU Transmission Fluid
9931493 R03 - 2020-2021 Sportsman XP 1000 S Service Manual
© Copyright Polaris Inc.
25 HOUR / 250 MILE (400 KM) SERVICE
REMARKS
Inspect
Break-in oil and filter change
Break-in fluid change
Inspect; cycle key to pressurize fuel pump; check lines and fittings for
leaks and abrasion.
Break-in fluid level check
50 HOUR / 500 MILE (800 KM) SERVICE
REMARKS
Check terminals; clean; test; replace as needed
Inspect
Check level
Check level
Lubricate
Inspect; cycle key to pressurize fuel pump; check lines and fittings for
leaks and abrasion.
Lubricate all fittings, pivots, cables, etc.
Inspect; clean external surfaces
Inspect
Inspect for leaks, loose joints, and wear
Lubricate
Inspect ducts for proper sealing / air leaks
Inspect; adjust; lubricate; replace if necessary
Check level
MAINTENANCE
2
2.5