Battery Identification; Lead Acid Conventional Battery; Lead Acid Conventional Battery Activation - Polaris Sportsman XP 1000 S 2020 Service Manual

BODY ELECTRICAL

BATTERY IDENTIFICATION

IMPORTANT
It is important to identify what type of battery is installed
in the vehicle. Different types of batteries require
different service procedures. Proper servicing and
upkeep of the battery is very important for maintaining
long battery life.
The types of batteries are
• Lead Acid Conventional
• Dry Shipped Absorbed Glass Mat (AGM)
• Lead Acid Low Maintenance
• AGM Low Maintenance
To identify which type of battery the vehicle has, refer to
the examples below and follow the correct service
procedures that follow in the manual.
LEAD ACID CONVENTIONAL / DRY
SHIPPED AGM BATTERY
• Battery NOT activated when packaged
• Removable cap plugs / strip on top of battery
• Distilled water added as required (Lead Acid only)
• Vent tube on side of battery (Lead Acid only)
LOW MAINTENANCE BATTERY
• Battery activated when packaged
• Non removable cap(s) on top of battery
• Distilled water or electrolyte NEVER added
12.14

LEAD ACID CONVENTIONAL BATTERY

LEAD ACID CONVENTIONAL BATTERY
ACTIVATION
CALIFORNIA PROPOSITION 65 WARNING:
Batteries, battery posts, terminals and related
accessories can expose you to chemicals including
lead, which is known to the State of California to cause
birth defects or other reproductive harm. For more
information go to www.P65Warnings.ca.gov.
Battery electrolyte is poisonous. It contains sulfuric
acid. Serious burns can result from contact with skin,
eyes or clothing. Antidote:
• External: Flush with water.
• Internal: Drink large quantities of water or milk.
Follow with milk of magnesia, beaten egg, or
vegetable oil. Call physician immediately.
• Eyes: Flush with water for 15 minutes and get
prompt medical attention.
Batteries produce explosive gases.
Keep sparks, flame, cigarettes, etc. away. Ventilate
when charging or using in an enclosed space. Always
shield eyes when working near batteries.
KEEP OUT OF REACH OF CHILDREN.
The gases given off by a battery are explosive. Any
spark or open flame near a battery can cause an
explosion which will spray battery acid on anyone close
to it. Should there be contact with battery acid, wash the
affected area with large quantities of cool water and
seek immediate medical attention.
IMPORTANT
Do not activate the battery unless it will be put into
regular service within 30 days. After initial service, add
only distilled water to the battery. Never add electrolyte
after a battery has been in service.
Battery must be fully charged before use or battery life
will be significantly reduced 10-30% of the battery's full
potential.
To activate a Lead Acid Conventional battery, do the
following:
9931493 R03 - 2020-2021 Sportsman XP 1000 S Service Manual
WARNING
WARNING
WARNING
© Copyright Polaris Inc.