Buell XB 2010 Service Manual page 368

HOME
FASTENER
Fuel supply line banjo fitting
Fuel tank vent valve fasteners
IAC actuator fasteners
Ignition coil mounting screws
inner engine shroud air scoop fastener
Intake flange screws
Interactive exhaust actuator fasteners
Manifold to engine mount fastener
Muffler mount fastener, front
Muffler mounting block fastener, rear
Muffler strap fastener, front
Muffler strap fastener, rear
Oil line p-clamp at swingarm
Outer engine shroud air scoop fastener
Oxygen sensor
Oxygen sensor
Rear electronic control module fastener,
Ulysses models
Rear shock absorber reservoir clamp
rear
Throttle position sensor
Torca clamp
Upper tie bar
4-2 2010 XB Service: Fuel System
TORQUE VALUE
84-108 in-lbs 9.5-12.2 Nm
39-41 in-lbs 4.4-4.6 Nm
25-30 in-lbs 2.8-3.4 Nm
120-144 in-lbs 13.6-16.3 Nm
12-36 in-lbs 1.4-4 Nm
96-120 in-lbs 10.8-13.6 Nm
36-40 in-lbs 4-4.5 Nm
90-120 in-lbs 10-13.6 Nm
-19-21 ft-lbs 25.8-28.5 Nm
32-36 ft-lbs 43.4-48.8 Nm
108-120 in-lbs 12.2-13.6 Nm
36-48 in-lbs 4.1-5.4 Nm
48-72 in-lbs 5.4-8 Nm
21.6-26.4 in-lbs 2.4-3 Nm
40-45 ft-lbs 54.2-61 Nm
40-45 ft-lbs 54.2-61 Nm
36-60 in-lbs 4-6.8 Nm
120-144 in-lbs 13.6-16.3 Nm
12-15 in-lbs 1.4-1.7 Nm
45-50 ft-lbs 61-67.8 Nm
25-27 ft-lbs 33.9-36.6 Nm
NOTES
4.14 FUEL PUMP, Installation
4.12 FUEL TANK VENT VALVE, Installation
4.15 THROTTLE BODY, Repair
4.6 IGNITION COIL, Installation
4.7 OXYGEN SENSORS (O2), Installation
4.15 THROTTLE BODY, Installation
4.3 AIR CLEANER ASSEMBLY, Installation
4.15 THROTTLE BODY, Installation
4.19 EXHAUST SYSTEM, Assembly and Installa-
tion
4.19 EXHAUST SYSTEM, Assembly and Installa-
tion/LOCTITE 27 (red)
4.19 EXHAUST SYSTEM, Assembly and Installa-
tion
4.19 EXHAUST SYSTEM, Assembly and Installa-
tion/You need to alternately tighten the fasteners
to torque a total of two times to make sure the
straps are evenly tightened.
4.19 EXHAUST SYSTEM, Assembly and Installa-
tion
4.7 OXYGEN SENSORS (O2), Installation
4.7 OXYGEN SENSORS (O2), Installation/ANTI-
SEIZE
4.7 OXYGEN SENSORS (O2), Installation/ANTI-
SEIZE
4.4 ELECTRONIC CONTROL MODULE
(ECM), Ulysses
4.20 EVAPORATIVE EMISSIONS CONTROL (CA
MODELS), Installation: Firebolt
4.5 THROTTLE POSITION SENSOR
(TPS), Installation/LOCTITE 222 (purple)
4.19 EXHAUST SYSTEM, Assembly and Installa-
tion
4.8 ENGINE TEMPERATURE SENSOR
(ET), Installation