Dodge ZB 2005 Service Manual page 1055

24 - 26 DISTRIBUTION
AIR OUTLETS
DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . . . 26
REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . 26
BLOWER MOTOR
DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . . . 27
OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
DIAGNOSIS AND TESTING
BLOWER MOTOR
REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . 28
DEFROSTER DUCTS
REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
AIR OUTLETS
DESCRIPTION
There are four air outlets in the instrument panel,
one located near each outboard end of the instrument
panel facing the rear of the vehicle, and two located
near the top of the instrument panel center bezel.
The air outlets cannot be serviced separately.
Each of the instrument panel air outlets contain an
air outlet barrel that is used to direct or shut off the
flow of the conditioned air leaving the instrument
panel.
All of the instrument panel air outlets barrels can
be serviced individually.
REMOVAL
NOTE: The instrument panel air outlet barrels are
retained into the air outlets by a light snap fit.
(1) Using a trim stick C-4755 or equivalent, gently
pry on the instrument panel air outlet barrel(s) until
the barrel retainers release from the pivot shafts of
the air outlets (Fig. 1).
(2) Remove the barrel(s) from the air outlet(s). If
needed, use a trim stick to help remove the barrels.
INSTALLATION
(1) Position the air outlet barrel(s) into the air out-
let(s).
(2) Gently push the barrel(s) into the air outlet(s)
until it snaps into position on the outlet pivot shafts.
DISTRIBUTION
TABLE OF CONTENTS
. . . . . . . . . . . . . . . . . . . . . 27
page
INSTALLATION
FLOOR DISTRIBUTION DUCT
REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
INSTALLATION
HVAC HOUSING
REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
DISASSEMBLY
ASSEMBLY
INSTALLATION
INSTRUMENT PANEL DUCTS
REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
INSTALLATION
1 - AIR OULET BARREL (4)
2 - AIR OUTLET
3 - INSTRUMENT PANEL
. . . . . . . . . . . . . . . . . . . . . . . . . 29
. . . . . . . . . . . . . . . . . . . . . . . . . 30
. . . . . . . . . . . . . . . . . . . . . . . . . 31
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
. . . . . . . . . . . . . . . . . . . . . . . . . 32
. . . . . . . . . . . . . . . . . . . . . . . . . 33
Fig. 1 Air Outlet Barrels
ZB
page