Chrysler Sebring 2004 Service Manual page 2993

VEHICLE THEFT/SECURITY
Symptom:
*HEADLAMPS INOPERATIVE WITH ALARM TRIPPED (IF EN-
ABLED)
LOW BEAM HEADLAMPS INOPERATIVE
BODY CONTROL MODULE INTERNAL MALFUNCTION
BODY CONTROL MODULE INTERNAL MALFUNCTION
HEADLAMP DELAY RELAY
JUNCTION BLOCK - OPEN FUSED B(+) CIRCUIT
JUNCTION BLOCK - OPEN HEADLAMP DELAY RELAY CONTROL CIRCUIT
HEADLAMP DELAY RELAY
TEST
1 Turn the Low Beam Headlamps on.
Do the Low Beam Headlamps operate properly?
Yes → Go To 2
No
2 Turn the Headlamps off.
With the DRBIII , actuate the Headlamp Delay Relay.
Do the Headlamps flash while actuating the Headlamp Delay Relay?
Yes → Replace the Body Control Module.
No
3 Remove the Headlamp Delay Relay from the Junction Block.
Temporarily remove the Horn Relay from the Junction Block.
Reinstall the Horn Relay in place of the Headlamp Delay Relay.
With the DRBIII , actuate the Headlamp Delay Relay.
Do the Headlamps flash while actuating the Headlamp Delay Relay?
Yes → Replace the Headlamp Delay Relay.
No
4 Remove the Horn Relay from the Headlamp Delay Relay location in the Junction
Block.
Reinstall the Horn Relay to its original location.
Measure the voltage of the Fused B(+) circuits at the Headlamp Delay Relay
connector.
Is the voltage above 10.0 volts at each cavity?
Yes → Go To 5
No
POSSIBLE CAUSES
ACTION
→ Refer to symptom LOW BEAM HEADLAMPS WILL NOT TURN
ON in the EXTERIOR LIGHTING category.
→ Go To 3
→ Go To 4
→ Refer to symptom HEADLAMP TIME DELAY INOPERATIVE in
the EXTERIOR LIGHTING category.
444
APPLICABILITY
All
All
All
All