Air Intake System; Air Filter Replacement; Air Canister Removal - Club Car Carryall 295 Maintenance And Service Manual
Hide thumbs
Also See for Carryall 295:
- Maintenance and service manual (456 pages) ,
- Owner's manual (72 pages) ,
- Owner's manual (84 pages)
Table of Contents
Advertisement
16
Air Intake System
AIR INTAKE SYSTEM
See General Warnings, Section 1, Page 1-2.
AIR FILTER REPLACEMENT
The air filter should be inspected periodically and replaced when necessary. Filter changes should not exceed the
recommended interval. See Periodic Service Schedule, Section 10, Page 10-1. More frequent service may be
required in extremely dirty operating environments. In the event of a loss of power, sluggish acceleration, or a roughly
running engine, service the air filter immediately.
CAUTION
• Do not drill into the driver-side frame because it is part of the air intake system. Failure to heed
this caution could damage the engine by allowing excessive contamination or water to enter the
air intake system.
Air Filter Removal
1.
Release both canister tab locks (Figure 16-22, Page 16-22).
2.
Pull the canister cap away from the canister.
3.
Remove the air filter cartridge. See following NOTE.
NOTE: The air filter cartridge is specifically designed for this engine. It only fits into the canister one way. Use
only direct replacement part (CC P/N 102498601).
Air Filter Installation
1.
Push the new filter cartridge onto the inside canister nozzle.
2.
Place the canister cap, marked TOP, on the top center of the canister (Figure 16-22, Page 16-22).
3.
Secure the canister cap with both tab locks.
1
218
Figure 16-22 Air Filter Cartridge
AIR CANISTER REMOVAL
1.
Disconnect battery. See Disconnecting the Battery – Gasoline/Diesel Vehicles, Section 1, Page 1-3.
Page 16-22
2013 Carryall 295/XRT 1550 Maintenance and Service Manual
DIESEL ENGINE, MUFFLER, FUEL SYSTEM,
AND CLUTCHES
Advertisement
Table of Contents
Troubleshooting
