Club Car Carryall 295 Maintenance And Service Manual page 320
Hide thumbs
Also See for Carryall 295:
- Maintenance and service manual (456 pages) ,
- Owner's manual (72 pages) ,
- Owner's manual (68 pages)
Table of Contents
Advertisement
16
Fuel System
4.
Turn the valve in the direction shown until water begins to stream from the filter.
5.
Drain water into the pan until the fluid changes color (to fuel). See following WARNING.
WARNING
• Clean up spilled fuel. Keep sparks and flames away from the vehicle and service area. Failure to heed
this warning could result in an explosion or fire, resulting in severe personal injury or death.
6.
Close the valve by rotating it in the opposite direction until the valve is firmly sealed and detach the drain hose.
See following NOTE.
NOTE: Dispose of water according to the environmental laws and regulations for your area.
2327
Figure 16-9 Fuel Filter with Water Separator
Fuel Filter Removal
See General Warnings, Section 1, Page 1-2.
The fuel filter also functions as a water separator. It has a drain valve on the bottom of the filter to drain water from the
fuel system. See Draining Water from the Fuel Filter above.
1.
Disconnect battery. See Disconnecting the Battery – Gasoline/Diesel Vehicles, Section 1, Page 1-3.
2.
Place a large pan under the fuel filter to catch fuel.
3.
Turn filter counterclockwise to remove from the filter manifold. Drain the residual fuel in the manifold and filter into
the drain pan. See following WARNING.
WARNING
• Clean up spilled fuel. Keep sparks and flames away from the vehicle and service area. Failure to heed
this warning could result in an explosion or fire, resulting in severe personal injury or death.
Fuel Filter Installation
See General Warnings, Section 1, Page 1-2.
1.
Use a clean, lint-free rag to wipe the filter manifold surface clean where the fuel filter gasket seats.
2.
To help seal the new fuel filter to the manifold, apply a light coat of new engine oil to the rubber seal before
installing filter (Figure 16-8, Page 16-8).
3.
Install new fuel filter (diesel: CC P/N 103761801) on the manifold. Tighten the filter by hand a fraction of a turn
until filter hits positive stop. Do not use a band wrench or channel lock pliers.
Page 16-10
2013 Carryall 295/XRT 1550 Maintenance and Service Manual
1
DIESEL ENGINE, MUFFLER, FUEL SYSTEM,
AND CLUTCHES
Advertisement
Table of Contents
Troubleshooting
