Club Car Carryall 295 Maintenance And Service Manual page 125

PERIODIC MAINTENANCE
PERIODIC SERVICE SCHEDULE
REGULAR INTERVAL
Semiannual service by trained technician
only (or every 50 hours of operation,
whichever comes first)
Annual service by trained technician only
(or every 100 hours of operation, whichever
comes first)
Every 200 hours of operation by trained
technician only.
WARNING
• If any problems are found during scheduled inspection or service, do not operate vehicle until repairs
are made. Failure to make necessary repairs could result in fire, property damage, severe personal
injury, or death.
SERVICE
Battery
Front wheel alignment and toe-in
Electrical wiring and connections
Brake system
Engine
Radiator
Engine air intake system
General vehicle
Fuel filters
Safety decals
Drive Belt
2013 Carryall 295/XRT 1550 Maintenance and Service Manual
Periodic Service Schedule – IntelliTach
Clean terminals and wash dirt from casing;
check electrolyte level. Add distilled water if
necessary. See page .
Check and adjust if necessary. See Steering
and Front Suspension Section in the
appropriate maintenance and service
manual.
Check for tightness and damage.
Inspect master cylinder, brake lines, and hoses
for damage or leakage.
Check park brake cables for damage; replace
if necessary.
Check brake pads and discs; replace if
necessary. For brake wear-in procedure,
see Hydraulic Brakes in the . See also
Brake System Section in the appropriate
maintenance and service manual.
Check for leaks around gaskets, fill plugs, etc.
Diesel vehicles: Check the v-belt for proper
tension or damage. Adjust or replace if
necessary.
Diesel vehicles: Change engine coolant. See
Radiator and Cooling System Section in
the maintenance and service manual.
Diesel vehicles: Check clamps for tightness;
check hoses for cracks. Replace if necessary.
Replace air filter element.
Check clamps for tightness; check hose for
cracks.
Check for loose hardware and tighten if
necessary.
Replace. Dispose of used filters properly.
Check safety decals. Replace if damaged or
illegible.
Inspect drive belt for cracks/damage. Replace
if necessary.
10
Page 10-5