Club Car Carryall 295 Maintenance And Service Manual page 282

15
Fuel System
If the carburetor has failed, replace it. See the Kawasaki FH680D engine manual (CC P/N 103351201).
Carburetor Grounding
WARNING
• The carburetor is equipped with an electric heater and must be grounded to the engine in order to
prevent the risk of a spark. Always have a ground wire properly installed.
The carburetor is equipped with an electric heater and must be grounded to the engine in order to prevent the risk of a
spark. Always have a ground wire installed (Figure 15-6, Page 15-10). If a ground wire is not present and installed
properly, do not operate the vehicle until carburetor is properly grounded. A Ground Wire Kit (CC P/N 103474701) is
available through Service Parts.
1. Carburetor Ground Wire 2. Electric Heater
1454
Figure 15-6 Carburetor Ground Wire
Carburetor Jetting
The Kawasaki FH680D engine is equipped with a carburetor that has fixed jets. These fixed jets do not require
adjustment. The size of the main jet is determined by the altitude where the engine will be operating. The main jet size
is set for the operating elevation of customer destination at the time of manufacture. In the event that carburetor jetting
needs to be changed, determine the proper jet size for the operating altitude. See Main Jet Elevation/Size Chart
on page 15-10. After the proper jet size is determined, replace the main jet. See the Kawasaki FH680D engine
manual (CC P/N 103351201).
No adjustment of the pilot air screw is recommended.
The following chart lists the elevation ratings for various jet sizes.
Main Jet Elevation/Size Chart
KAWASAKI FH680
ENGINE
MODEL/REVISION
AS09, BS09
TABLE CONTINUED ON NEXT PAGE
Page 15-10 2013 Carryall 295/XRT 1550 Maintenance and Service Manual
1
CARBURETOR
NUMBER
0-3300 FT. (0-1000 M)
47007
47038
GASOLINE ENGINE, MUFFLER, FUEL
JET SIZE
3300-6600 FT.
(1000-2000 M)
102/102 99/99
SYSTEM, AND CLUTCHES
6600 FT. AND HIGHER
(2000 M AND HIGHER)
96/96