Club Car Carryall 295 Maintenance And Service Manual page 165

TROUBLESHOOTING AND ELECTRICAL SYSTEM:
GASOLINE VEHICLES
TEST PROCEDURE 15 – Neutral Switch (Transmission)
See General Warnings, Section 1, Page 1-2.
The neutral switch is located on the transmission housing.
1. Disconnect battery and spark plug wire(s). See Disconnecting the Battery – Gasoline/Diesel Vehicles on
page 1-3.
2. Disconnect the two-pin connector between the neutral switch and the wire harness (w138 and w143) (Figure
11-16, Page 11-23).
3. Check for continuity on the switch contacts with the Forward/Reverse handle in the FORWARD position (Figure
11-17, Page 11-23). The multimeter should indicate no continuity.
2090
Figure 11-16 Neutral Switch Two-Pin Connector
2092
Figure 11-18 Neutral Switch – Neutral Position
4. Check for continuity on the switch contacts with the Forward/Reverse handle in the NEUTRAL position (Figure
11-18, Page 11-23). The multimeter should indicate continuity.
2091
2094
2013 Carryall 295/XRT 1550 Maintenance and Service Manual
Figure 11-17 Neutral Switch – Forward Position
Figure 11-19 Neutral Switch – Reverse Position
11
Test Procedures
Page 11-23