Polaris Sportsman 800 EFI 4x4 2012 Service Manual page 26

MAINTENANCE
ITEM
Oil tank vent hose (if
▶, E
applicable)
■, E Fuel system
Radiator
▶
(if applicable)
Cooling hoses
▶
(if applicable)
▶ Engine mounts
Exhaust
muffler/pipe
■, E Spark Plug
Ignition Timing
■, E
▶ Wiring
Clutches
■
(drive & driven)
Front wheel bearings
■
■
Brake fluid
■
ADC fluid
Spark arrestor
Idle Speed
E
Toe Adjustment
■
■, ▶
Auxiliary brake
Headlight aim
*** Service Note: Under extreme use, change demand drive fluid every 25 hours. "Extreme Use" is defined as constant ADC operation on hilly or
mountainous terrain, or if ADC is the primary mode of operation.
▶ = Perform these procedures more often for vehicles subjected to severe use.
E = Emission Control System Service (California)
■ = Have an authorized Polaris Dealer perform these services.
2.6
REQUIRED MAINTENANCE INTERVALS
MAINTENANCE INTERVAL
HOUR-
CALEN-
MILES (KM)
S DAR
1000 (1600)
100 H 12 M
1000 (1600)
100 H 12 M
1000 (1600)
100 H 12 M
1000 (1600)
100 H 12 M
1000 (1600)
100 H 12 M
1000 (1600)
100 H 12 M
1000 (1600)
100 H 12 M
1000 (1600)
100 H 12 M
1000 (1600)
100 H 12 M
1000 (1600)
100 H 12 M
1000 (1600)
100 H 12 M
2000 (3200)
200 H 24 M
2000 (3200)
200 H 24 M
3000 (4800)
300 H 36 M
—
—
—
—
9924864 - 2012-2014 SPORTSMAN 800 / 6X6
© Copyright 2013 Polaris Sales Inc.
REMARKS
Inspect routing, condition
Check for leaks at tank cap, lines, fuel pump, filter, pump,
injectors; replace lines every two years
Inspect; clean external surfaces
Inspect for leaks
Inspect
Inspect
Inspect; replace as needed
Inspect
Inspect for wear, routing, security; apply dielectric grease to
connectors subjected to water, mud, etc.
Inspect; clean; replace worn parts
Inspect; replace as needed
Change every two years
Change every two years
Clean out
Adjust as needed
Inspect periodically; adjust when parts are replaced
Inspect daily, adjust as needed
Adjust as needed