Inspection Of Intermittent And Poor Connections - Suzuki 2006 SX4 Service Manual

8B-89 Air Bag System:
Step
4 Contact coil circuit (horn, audio control and cruise
control switch circuit) check (cruise control model)
1) Check for continuity between each terminal of horn
switch terminals, audio control switch terminals and
cruise control switch terminals as shown in figure.
A
B
C
D
E
F
Is each measured resistance 3
5 Contact coil circuit check
1) Measure resistance between each terminal and other
terminal.
Is each measured resistance infinity?
Inspection of Intermittent and Poor
Connections
Most intermittents are caused by faulty electrical
connections or wiring. When a check for proper
connection is requested in a diagnostic flow, perform
careful check of suspect circuits.
If any abnormality is found, repair or replace as a wire
harness assembly.
• Poor mating of connector halves, or terminals not fully
seated in the connector body (backed out).
Action
A B C D E F
G H I J
a b c d e f
g h i j k l
Terminal Terminal
a G
H
b
c I
d
J
e
K
L
f
Ω
or less?
S6RW0D8204047
Go to Step 5.
K L
g
h
i
j
k
l
I7RW01822113-01
Contact coil and its
circuit are good
condition.
• Dirt or corrosion on the terminals. The terminals must
be clean and free of any foreign material which could
impede proper terminal contact.
However, cleaning the terminal with a sand paper or
the like is prohibited.
• Damaged connector body, exposing the terminals to
moisture and dirt, as well as not maintaining proper
terminal orientation with the component or mating
connector.
Yes
Replace contact coil.
Replace contact coil.
No