A/T Fluid Change - Suzuki Liana RH413 Service Manual

5A-80 Automatic Transmission/Transaxle:
Level Check at Room Temperature – Cold Check
Fluid level can be checked temporarily at room
temperature which correspond to 20 – 30 °C (68 – 86
°F). This level check is considered to be preparation
before performing level check under normal operating
temperature. Checking procedure itself is the same as
that described in "Level Check at Normal Operation
Temperature – Hot Check: ". If fluid level is between
"FULL COLD" (4) and "LOW COLD" (5), proceed to test
drive. And when fluid temperature has reached normal
operating temperature, check fluid level again and adjust
it as necessary.
CAUTION
!
Fluid level check at room temperature is
recommended only for preparation of level
check under normal operating condition.
Failure to perform fluid level check under
normal operating temperature may result in
damage to transaxle.
1 2
1. Fluid level gauge
2. "FULL HOT" mark
3. "LOW HOT" mark
1
3 4 5
I2RH0B510037-01

A/T Fluid Change

1) Lift up vehicle.
2) When engine is cool, remove drain plug (1) and
drain A/T fluid.
3) Install drain plug (1).
Tightening torque
A/T fluid drain plug (a): 17 N·m (1.7 kgf-m, 12.5
lb-ft)
4) Lower vehicle and pour proper amount of an
equivalent of DEXRON
5) Check fluid level referring to "A/T Fluid Level Check".
Automatic transaxle fluid
An equivalent of DEXRON
Automatic transaxle fluid capacity
When draining from drain plug hole: 3.3 liters
(6.97 / 5.81 US/Imp. pt.)
When overhauling: 5.6 liters (11.83 / 9.86 US/Imp.
pt.)
1 2
1. Fluid level gauge
2. "FULL HOT" mark
3. "LOW HOT" mark
S3RH0A5106002
1
I2RH0B510038-01
®
-III.
®
-III
1
3 4 5
I2RH0B510037-01
4. "FULL COLD" mark
5. "LOW COLD" mark