CareFusion Alaris 8110 series Service Manual page 122

ILLUSTRATED PARTS BREAKDOWN
Syringe Module
Parts List - Syringe Module (Continued)
Table 7A-1.
Item Part Number
496 321035
499
645 148013-000
646 125569
2003 147077-100
2004 147078-100
2006 147080-100
10010720
10010199
10012555
10012398
148089-001
Replacement of the Complete Housing Assembly, Force Sensor Assembly or Logic Board Assembly in a
Syringe Module with version
section for further information.
7.4
CAUTIONS
• The Top disk Holder, Internal Frame, Shaft Support and various Syringe Barrel Clamp Assembly parts
identified here are not backwards compatible with a Syringe Barrel Clamp Assembly having a Park
Position "Pin" attached. Prior to ordering any of these parts, reference the "Corrective Maintenance"
chapter for part identification and replacement instructions.
• Newer versions of the Park Position Collar and Barrel Clamp are not interchangeable with earlier
versions. If either part requires replacement and the hex head bit,
remove the Park Position Collar
Order the Front Case "Kit" when replacing an "old version" Front Case, Syringe Barrel Clamp Assembly (or
associated part), or Top Disk Holder (reference Figure
Order the Front Case "Assembly" when replacing a "new version" Front Case, Syringe Barrel Clamp Assembly
(or associated part), or Top Disk Holder (reference Figure
The Base Disk Holder can be relaced as an individual part only if it is used with a "new version" Front Case. If
an "old version" Front Case is in use, order item 9, Front Case "Kit" (reference Figure
Not sold by Carefusion.
7A-6
Alaris Syringe Module (8110 Series)
®
Alaris PCA Module (8120 Series)
®
Technical Service Manual
/
Screw, 4-40 x , PNH PHH
3
4
Silicone Grease, Dow Corning Molykote 33, or equivalent (use with
item )
410
Label, Patent
Label, Serial Number Replacement
IUI Connector Kit, Right
(Includes: Right Gasket, Right
IUI Connector Kit, Left
(Includes: Left Seal, Left
Latch Kit
(Includes: Latch, Compression Spring, Leaf Spring, Support)
Directions for Use:
PCA Module (V7)
Syringe Module (V7)
Alaris System (supports Guardrails
®
Electronic Copy
Printed Copy
Set Compatibility Card
or earlier software must be performed at the depot. Refer to the note in
7
" setscrew, both parts must be replaced.
0.062
Description
Connector)
IUI
Connector)
IUI
Suite MX):
®
/
,
1 HX
16
).
7A-7
).
7A-7
As required
/
" length tool was used to
1 15
16
).
7A-7
QTY
6
1
1
1
1
1
1
1