Graco InvisiPac HM10 Instructions Manual page 115

Common System Parts
Ref. Part Description
201 - - - - - Electrical Enclosure
202 25M525 AMZ Circuit Board Assembly
203 125856 Serrated Flange Screw, 8-32
204 123967 Operator Disconnect Knob
205 126881 Strain Relief Bushing
206 126891 Bushing Nut
207 114421 Strain Relief Bushing
208 129598 Snap-In Grip Cord
209 - - - - - Dowel Pin
210 121487 Grommet (electrical enclosure) 3
211 127887 Power Supply, 24 DC, 6.3 A
212 109466 Lock Hex Nut
213 102360 Flat Washer
214 117666 Ground Terminal
215 115942 Flange Head Hex Nut
216 129542 Plug Connector, 5.08 mm (4
position)
217 129192 Plug Connector, 5.08 mm (3
position)
218 128116 Plug Connector, 3.81 mm (7
position)
219 129539 Plug Connector, 3.81 mm (3
position)
220 129541 Plug Connector, 5.08 mm (4
position)
221 25P567 Fuse Holder Harness
Assembly, 8 Leads
222 129537 Plug Connector, 5.08 mm (8
position)
223 - - - - - Melter Pump with Air Motor,
See Melter Pump Assembly:
20B911, page 116
224 - - - - - Rear Melter Cover
225 - - - - - Air Control Assembly, see Air
Regulator Assembly, page
118
226 113161 Hex Head Flange Screw
227★ - - - - - Funnel Coupler
228★ - - - - - Melter Funnel
229★ 278871 Funnel Inlet
230★ - - - - - Sensor Housing
231 130165 Machine Screw, Pan Head,
10-32 x 2.5 in.
232 110932 Male Connector
3A7259C
Ref. Part
233 126780
Qty.
234★ 24R885 Reed Switch Assembly (cycle
1
1
235 104641 Bulkhead Fitting
8
236 - - - - -
1
237 157021 Lock Washer (Cycle Switch)
1
238★ - - - - -
1
239 129197 Disconnect Switch
2
240 129869 Level Sensor (Ultrasonic)
2
241★ 129908 Funnel Air Filter
2
242★ 278873 Funnel Cover
243★ 129813 O-Ring, Viton
1
244★ 17J898 Hose Clamp, 2-9/16-3-1/2
4
245★ 297331 Cap Screw (Over-Temperature
6
1
246 126901 Thread Forming Screw, #10-16 1
7
248 17M274 Molex Cable, M12
1
249 17R646 Molex Cable, M8
250 598095 Nylon Tube, 5/32 OD
1
252 17M487 Melter Temperature Sensor,
2
254 17M295 Harness, OT
255★ - - - - -
2
256 16T440 Electrical Cap
260 - - - - -
1
261 24P175 Electrical Enclosure Plate
1
262 19A770 PTC Elbow Fitting, 1/4 in. to
1
263 129902 Restrictor, .023,1/4 tube x 1/4
1
264 107388 Temperature Sensor Screw,
265 121000 Can Cable, female 0.5m
1
266 102920 Lock Nut
1
267 129538 Plug Connector, 3.81 mm (4
3 ★ Included in a repair kit. See Repair Kits, page 119
for details.
1
1
1
1
3
1
Description
Over-Temperature Switch
switch kit)
Triple Union Fitting, 1/4 tube
Pan Head Screw, 8-32 x 1.5 in. 1
Switch)
1000 ohm rtd
PTFE Tube, 1/4 in. OD
Electrical Enclosure Foam
Gasket
5/32 in.
tube
Pan Head Machine Screw
position)
Parts
Qty.
1
1
1
1
1
1
1
1
1
2
2
2
1
1
1.34 ft
1
1
1.13 ft
4
1
1
1
1
1
1
3
1
115