BOMBARDIER SEA-DOO SPX 5838 1998 Shop Manual page 38

F07D07A
1. Drain plug
Drain completely the crankcase oil of the counter-
balance shaft. Reinstall drain plug with Loctite
515.
Add 30 mL (1 oz) of SAE 30 motor oil.
Reinstall filler plug.
947 Engine
Siphon the oil and add 40 mL (1.35 oz) of SAE 30
motor oil.
Reinstall filler plug.
All Models
Turn fuel valve to ON position.
Start engine; It may be necessary to use the
choke. If engine does not start, repeat previous
steps as necessary.
-
CAUTION
To avoid starting motor overheating, the
cranking period should not exceed 5-10 sec-
onds and a rest period of 30 seconds should
be observed between cranking cycles.
NOTE: If engine does not start after several at-
tempts, check ignition system for spark occur-
rence. Refer to IGNITION SYSTEM 08-02.
Check crankshaft if needed, it may be misaligned
or deflected. Refer to BOTTOM END 04-06.
After engine has started, spray BOMBARDIER
LUBE lubricant through air intake silencer while
engine is running.
1
Section 02 MAINTENANCE
Subsection 04 (WATER-FLOODED ENGINE)
1
F01F25A
717 AND 787 ENGINES
1. Air intake silencer
2. Pull plug
3. Spray BOMBARDIER LUBE here
2
F06F0CA
947 ENGINE
1. Air intake silencer
2. Spray BOMBARDIER LUBE here
Run engine until it reaches its normal operating
temperature.
-
Engine must be cooled using the flush kit.
2
3
1
CAUTION
02-04-3