Checking The Vehicle Power - Yamaha TMAX XP530E-A 2017 Service Manual

EAS31453
TROUBLESHOOTING
Vehicle power does not turn on. (Meter light and tail/brake light do not come on.)
Engine does not start even though vehicle power is turned on.
Seat/fuel lid or storage compartment lid (for XP530-A/XP530D-A) does not open. (Vehicle power is
turned on.)
TIP
Before troubleshooting, remove the following part(s):
1. Front cowling assembly
2. Handlebar cover (front)
3. Storage box

Checking the vehicle power

1. Check the smart key.
 The smart key indicator light
comes on when the ON/OFF switch
" " is pushed.
 Check the button cell battery.
Refer to "CHECKING THE SMART
KEY BATTERY" on page 8-250.
OK
2. Check the fuses.
(Main, backup, and ignition)
Refer to "CHECKING THE FUSES"
on page 8-229.
OK
3. Check the battery.
Refer to "CHECKING AND
CHARGING THE BATTERY" on
page 8-230.
OK
4. Check the ON/start switch.
Refer to "CHECKING THE
SWITCHES" on page 8-221.
OK
5. Check the ignition system relay.
Refer to "CHECKING THE RE-
LAYS" on page 8-233.
OK
6. Check the entire smart key system's
wiring.
Refer to "CIRCUIT DIAGRAM" on
page 8-193.
OK
Replace the remote control unit.
Replace the button cell battery of the
smart key. Standard battery: CR2025
NG
Replace the fuse(s).
NG
• Clean the battery terminals.
• Recharge or replace the battery.
NG
The ON/start switch is faulty. Replace the
handlebar switch (right).
NG
Replace the ignition system relay.
NG
Properly connect or replace the wire har-
ness.
NG
8-199
SMART KEY SYSTEM